Grundfos MAGNA1 Series Installation And Operating Instructions Manual

Marca: Grundfos

Model: MAGNA1 Series

Tip: Installation And Operating Instructions Manual

Acest manual este potrivit și pentru

MAGNA3 25-100 (N)

GRUNDFOS INSTRUCTIONS

MAGNA3

Safety instructions and other important information

Installation and operating instructions

http://net.grundfos.com/qr/i/98091805

English (GB)

English (GB) Safety instructions

Original safety instructions

These safety instructions give a quick

overview of the safety precautions to be

taken in connection with any work on this

product.

Observe these safety instructions during

handling, installation, operation,

maintenance, service and repair of this

product.

These safety instructions are a

supplementary document, and all safety

instructions will appear again in the relevant

sections of the installation and operating

instructions.

Keep these safety instructions at the

installation site for future reference.

General warning

Read this document and the quick

guide before installing the product.

Installation and operation must comply

with local regulations and accepted

codes of good practice.

English (GB)

Type key

This appliance can be used by

children aged from 8 years and above

and persons with reduced physical,

sensory or mental capabilities or lack

of experience and knowledge if they

have been given supervision or

instruction concerning use of the

appliance in a safe way and

understand the hazards involved.

Children shall not play with the

appliance. Cleaning and user

maintenance shall not be made by

children without supervision.

CodeExample (D) 32 -40 (F) (N) 220

Type range

MAGNA3

Single-head pump

Twin-head pump

Nominal diameter

(DN) of suction and

discharge ports [mm]

Maximum head [dm]

English (GB)

Lifting the pump

Installing the product

Pipe connection

Threaded

Flange

Pump housing material

Cast iron

Stainless steel

Port-to-port length [mm]

Observe local regulations concerning

limits for manual lifting or handling.

Do not lift the pump head by the

control box, i.e. the red area of the

pump.

CAUTION

Pressurised system

Minor or moderate personal injury

- Pay special attention to any

escaping vapour when loosening

the clamp.

CodeExample (D) 32 -40 (F) (N) 220

English (GB)

CAUTION

Crushing of feet

Minor or moderate personal injury

- Do not drop the pump head when

loosening the clamp.

Fit and tighten the screw that holds the

clamp to 8 Nm ± 1 Nm. Do not apply

more torque than specified even

though water is dripping from the

clamp. The condensed water is most

likely coming from the drain hole under

the clamp.

Check the position of the clamp before

you tighten the clamp. Incorrect

position of the clamp will cause

leakage from the pump and damage

the hydraulic parts in the pump head.

Do not insulate the control box or

cover the operating panel.

8Nm!

English (GB)

Electrical installation

WARNING

Electric shock

Death or serious personal injury

- Before starting any work on the

product, make sure that the power

supply has been switched off. Lock

the main switch in position 0. Type

and requirements as specified in EN

60204-1, 5.3.2.

English (GB)

WARNING

Electric shock

Death or serious personal injury

- Connect the pump to an

external main switch with a

minimum contact gap of 3 mm in

all poles.

- Use earthing or neutralisation

for protection against indirect

contact.

- If a plug-connected pump is

connected to an electric

installation where an electrical

circuit breaker (voltage sensing

ELCB, residual-current device

RCD or residual-current circuit

device RCCB) is used as an

additional protection, this circuit

breaker must be marked with

the first or both of the symbols

shown below.

If the pump is

terminal-connected, the circuit

breaker must be marked with

both of the symbols below.

English (GB)

Product introduction

Radio communication

The radio part of this product is a class 1

device and can be used anywhere in the EU

member states without restrictions.

Intended use

This pump incorporates a radio for remote

control.

Make sure that the fuse is

dimensioned according to the

nameplate and local legislation.

Connect all cables in accordance with

local regulations.

Make sure that all cables are

heat-resistant up to 75 °C.

Install all cables in accordance with

EN 60204-1 and EN 50174-2:2000.

Do not pump aggressive liquids.

Do not pump flammable, combustible

or explosive liquids.

English (GB)

The pump can communicate with Grundfos

GO and with other MAGNA3 pumps of the

same type via the built-in radio.

Control functions

WARNING

Electric shock

Minor or moderate personal injury

- Separate wires connected to supply

terminals, outputs NC, NO, C and

start-stop input from each other and

from the supply by reinforced

insulation.

Make sure that all cables are

heat-resistant up to 75 °C.

Install all cables in accordance with

EN 60204-1 and EN 50174-2:2000.

Connect all cables in accordance with

local regulations.

English (GB)

Setting the product

WARNING

Electric shock

Death or serious personal injury

- Separate input voltages from

external equipment from live parts

by reinforced insulation.

CAUTION

Hot surface

Minor or moderate personal injury

- At high liquid temperatures, the

pump housing may be so hot that

only the control panel should be

touched to avoid burns.

Set the operating mode to "Normal"

before you enable a control mode.

English (GB)

Servicing the product

WARNING

Electric shock

Death or serious personal injury

- Switch off the power supply for at

least 3 minutes before you start any

work on the product.

- Lock the main switch in position 0.

Type and requirements as specified

in EN 60204-1, 5.3.2.

WARNING

Electric shock

Death or serious personal injury

- Make sure that other pumps or

sources do not force flow through

the pump even if the pump is

stopped. This will cause the motor

to act like a generator, resulting in

voltage on the pump.

English (GB)

Fault finding

WARNING

Magnetic field

Death or serious personal injury

- Persons with pacemakers

disassembling this product must

exercise care when handling the

magnetic materials embedded in the

rotor.

WARNING

Electric shock

Death or serious personal injury

- Switch off the power supply for at

least 3 minutes before you start any

work on the product. Lock the main

switch in position 0. Type and

requirements as specified in EN

60204-1, 5.3.2.

English (GB)

WARNING

Electric shock

Death or serious personal injury

- Make sure that other pumps or

sources do not force flow through

the pump even if the pump is

stopped.

If the power supply cable is damaged,

it must be replaced by the

manufacturer, the manufacturer's

service partner or a similarly qualified

person.

CAUTION

Pressurised system

Minor or moderate personal injury

- Before dismantling the pump, drain

the system or close the isolating

valve on either side of the pump.

The pumped liquid may be scalding

hot and under high pressure

English (GB)

Installing a communication interface

module

Technical data

Ambient temperature

0 to +40 °C.

WARNING

Electric shock

Death or serious personal injury

- Make sure that other pumps or

sources do not force flow through

the pump even if the pump is

stopped.

WARNING

Electric shock

Death or serious personal injury

- Switch off the power supply for at

least 3 minutes before you start any

work on the product.

- It must be possible to lock the main

switch in position 0. Type and

requirements as specified in EN

60204-1, 5.3.2.

English (GB)

Liquid temperature

Continuously: -10 to +110 °C.

Stainless-steel pumps in domestic hot-water

systems:

In domestic hot-water systems, we

recommend that you keep the liquid

temperature below 65 °C to eliminate the

risk of lime precipitation.

Maximum system pressure

The maximum permissible system pressure

is stated on the pump nameplate:

PN 6: 6 bar / 0.6 MPa

PN 10: 10 bar / 1.0 MPa

PN 16: 16 bar / 1.6 MPa.

Disposal

This product has been designed with focus

on the disposal and recycling of materials.

The following average disposal values apply

to all variants of pumps:

The actual inlet pressure and the

pump pressure against a closed valve

must be lower than the maximum

permissible system pressure.

English (GB)

• 85 % recycling

• 10 % incineration

• 5 % depositing.

This product or parts of it must be disposed

of in an environmentally sound way:

1. Use the public or private waste collection

service.

2. If this is not possible, contact the nearest

Grundfos company or service workshop.

The crossed-out wheelie bin symbol

on a product means that it must be

disposed of separately from

household waste. When a product

marked with this symbol reaches its end of

life, take it to a collection point designated

by the local waste disposal authorities. The

separate collection and recycling of such

products will help protect the environment

and human health.

See also end-of-life information at

www.grundfos.com/product-recycling.

English (GB)

WARNING

Magnetic field

Death or serious personal injury

- Persons with pacemakers

disassembling this product must

exercise care when handling the

magnetic materials embedded in the

rotor.

Appendix

Appendix 1

中国RoHS

ӗ૱ѝᴹᇣ⢙䍘Ⲵ਽〠৺ਜ਼䟿



䜘Ԧ਽〠

ᴹᇣ⢙䍘

䫵

;WďͿ

⊎

;,ŐͿ

䭹

;ĚͿ

ޝԧ䬜

;ƌϲнͿ

ཊⓤ㚄㤟

;WͿ

ཊⓤ㚄㤟䟊

;WͿ

⌥༣

y K K K K K

ঠࡧ⭥䐟ᶯ

y K K K K K

㍗പԦ

y K K K K K

㇑Ԧ

y K K K K K

ᇊᆀ

y K K K K K

䖜ᆀ

y K K K K K

ᵜ㺘Ṭ׍ᦞ ^:ͬdϭϭϯϲϰ Ⲵ㿴ᇊ㕆ࡦ



K˖㺘⽪䈕ᴹᇣ⢙䍘൘䈕䜘Ԧᡰᴹ൷䍘ᶀᯉѝⲴਜ਼䟿൷൘ 'ͬdϮϲϱϳϮ 㿴ᇊⲴ䲀䟿㾱≲ԕлǄ

y˖㺘⽪䈕ᴹᇣ⢙䍘㠣ቁ൘䈕䜘ԦⲴḀа൷䍘ᶀᯉѝⲴਜ਼䟿䎵ࠪ 'ͬdϮϲϱϳϮ 䈕㿴ᇊⲴ䲀䟿㾱≲Ǆ



䈕ӗ૱⧟؍֯⭘ᵏ䲀Ѫ ϭϬ ᒤˈḷ䇶ྲᐖമᡰ⽪Ǆ

↔⧟؍ᵏ䲀ਚ䘲⭘Ҿӗ૱൘ᆹ㻵о֯⭘䈤᰾Җѝᡰ㿴ᇊⲴᶑԦлᐕ֌

ӗ૱ѝᴹᇣ⢙䍘Ⲵ਽〠৺ਜ਼䟿

Declaration of conformity

Declaration of conformity 2

GB: EU declaration of conformity

We, Grundfos, declare under our sole responsibility that the product MAGNA3, to which the

declaration below relates, is in conformity with the Council Directives listed below on the

approximation of the laws of the EU member states.

BG: Декларация за съответствие на EO

Ние, фирма Grundfos, заявяваме с пълна отговорност, че продуктът MAGNA3, за който се отнася

настоящата декларация, отговаря на следните директиви на Съвета за уеднаквяване на

правните разпоредби на държавите-членки на ЕO.

CZ: Prohlášení o shodě EU

My firma Grundfos prohlašujeme na svou plnou odpovědnost, že výrobek MAGNA3, na který se toto

prohlášení vztahuje, je v souladu s níže uvedenými ustanoveními směrnice Rady pro sblížení právních

předpisů členských států Evropského společenství.

DE: EU-Konformitätserklärung

Wir, Grundfos, erklären in alleiniger Verantwortung, dass das Produkt MAGNA3, auf das sich diese

Erklärung bezieht, mit den folgenden Richtlinien des Rates zur Angleichung der Rechtsvorschriften

der EU-Mitgliedsstaaten übereinstimmt.

DK: EU-overensstemmelseserklæring

Vi, Grundfos, erklærer under ansvar at produktet MAGNA3 som erklæringen nedenfor omhandler, er

i overensstemmelse med Rådets direktiver der er nævnt nedenfor, om indbyrdes tilnærmelse til EU-

medlemsstaternes lovgivning.

EE: EÜvastavusdeklaratsioon

Meie, Grundfos, kinnitame ja kanname ainuisikulist vastutust selle eest, et toode MAGNA3, mille kohta

all olev deklaratsioon käib, on kooskõlas Nõukogu Direktiividega, mis on nimetatud all pool vastavalt

vastuvõetud õigusaktidele ühtlustamise kohta EÜ liikmesriikides.

ES: Declaración de conformidad de la UE

Grundfos declara, bajo su exclusiva responsabilidad, que el producto MAGNA3 al que hace referencia

la siguiente declaración cumple lo establecido por las siguientes Directivas del Consejo sobre la

aproximación de las legislaciones de los Estados miembros de la UE.

FI: EU-vaatimustenmukaisuusvakuutus

Grundfos vakuuttaa omalla vastuullaan, että tuote MAGNA3, jota tämä vakuutus koskee, on EU:n

jäsenvaltioiden lainsäädännön lähentämiseen tähtäävien Euroopan neuvoston direktiivien

vaatimusten mukainen seuraavasti.

FR: Déclaration de conformité UE

Nous, Grundfos, déclarons sous notre seule responsabilité, que le produit MAGNA3, auquel se réfère

cette déclaration, est conforme aux Directives du Conseil concernant le rapprochement des

législations des États membres UE relatives aux normes énoncées ci-dessous.

GR: Δήλωση συμμόρφωσης ΕΕ

Εμείς, η Grundfos, δηλώνουμε με αποκλειστικά δική μας ευθύνη ότι το προϊόν MAGNA3, στο οποίο

αναφέρεται η παρακάτω δήλωση, συμμορφώνεται με τις παρακάτω Οδηγίες του Συμβουλίου περί

προσέγγισης των νομοθεσιών των κρατών μελών της ΕΕ.

HR: EU deklaracija sukladnosti

Mi, Grundfos, izjavljujemo s punom odgovornošću da je proizvod MAGNA3, na koja se izjava odnosi

u nastavku, u skladu s direktivama Vijeća dolje navedenih o usklađivanju zakona država članica EU-a.

Declaration of conformity

HU: EU megfelelőségi nyilatkozat

Mi, a Grundfos vállalat, teljes felelősséggel kijelentjük, hogy a(z) MAGNA3 termék, amelyre az alábbi

nyilatkozat vonatkozik, megfelel az Európai Unió tagállamainak jogi irányelveit összehangoló tanács

alábbi előírásainak.

IT: Dichiarazione di conformità UE

Grundfos dichiara sotto la sua esclusiva responsabilità che il prodotto MAGNA3, al quale si riferisce

questa dichiarazione, è conforme alle seguenti direttive del Consiglio riguardanti il riavvicinamento

delle legislazioni degli Stati membri UE.

LT: ES atitikties deklaracija

Mes, Grundfos, su visa atsakomybe pareiškiame, kad produktas MAGNA3, kuriam skirta ši

deklaracija, atitinka žemiau nurodytas Tarybos Direktyvas dėl ES šalių narių įstatymų suderinimo.

LV: ES atbilstības deklarācija

Sabiedrība Grundfos ar pilnu atbildību paziņo, ka produkts MAGNA3, uz kuru attiecas tālāk redzamā

deklarācija, atbilst tālāk norādītajām Padomes direktīvām par ES dalībvalstu normatīvo aktu

tuvināšanu.

NL: EU-conformiteitsverklaring

Wij, Grundfos, verklaren geheel onder eigen verantwoordelijkheid dat product MAGNA3, waarop de

onderstaande verklaring betrekking heeft, in overeenstemming is met de onderstaande Richtlijnen van

de Raad inzake de onderlinge aanpassing van de wetgeving van de EU-lidstaten.

PL: Deklaracja zgodności UE

My, Grundfos, oświadczamy z pełną odpowiedzialnością, że nasz produkt MAGNA3, którego

deklaracja niniejsza dotyczy, jest zgodny z następującymi dyrektywami Rady w sprawie zbliżenia

przepisów prawnych państw członkowskich.

PT: Declaração de conformidade UE

A Grundfos declara sob sua única responsabilidade que o produto MAGNA3, ao qual diz respeito a

declaração abaixo, está em conformidade com as Directivas do Conselho sobre a aproximação das

legislações dos Estados Membros da UE.

RO: Declaraţia de conformitate UE

Noi Grundfos declarăm pe propria răspundere că produsul MAGNA3, la care se referă această

declaraţie, este în conformitate cu Directivele de Consiliu specificate mai jos privind armonizarea

legilor statelor membre UE.

RS: Deklaracija o usklađenosti EU

Mi, kompanija Grundfos, izjavljujemo pod punom vlastitom odgovornošću da je proizvod MAGNA3, na

koji se odnosi deklaracija ispod, u skladu sa dole prikazanim direktivama Saveta za usklađivanje

zakona država članica EU.

RU: Декларация о соответствии нормам ЕС

Мы, компания Grundfos, со всей ответственностью заявляем, что изделие MAGNA3, к которому

относится нижеприведённая декларация, соответствует нижеприведённым Директивам Совета

Евросоюза о тождественности законов стран-членов ЕС.

SE: EU-försäkran om överensstämmelse

Vi, Grundfos, försäkrar under ansvar att produkten MAGNA3, som omfattas av nedanstående

försäkran, är i överensstämmelse med de rådsdirektiv om inbördes närmande till EU-

medlemsstaternas lagstiftning som listas nedan.

SI: Izjava o skladnosti EU

V Grundfosu s polno odgovornostjo izjavljamo, da je izdelek MAGNA3,na katerega se spodnja izjava

nanaša, v skladu s spodnjimi direktivami Sveta o približevanju zakonodaje za izenačevanje pravnih

predpisov držav članic EU.

Pagina se încarcă ...

Grundfos MAGNA1 Series Installation And Operating Instructions Manual

Marca: Grundfos

Model: MAGNA1 Series

Tip: Installation And Operating Instructions Manual

Acest manual este potrivit și pentru

MAGNA3 25-100 (N)

Descărcați PDF

raport

în alte limbi

English: Grundfos MAGNA1 Series

Grundfos MAGNA1 Series Installation And Operating Instructions Manual

Acest manual este potrivit și pentru

Grundfos MAGNA1 Series Installation And Operating Instructions Manual

în alte limbi

Lucrări conexe

Alte documente