Briggs & Stratton Vanguard 520000 Manualul proprietarului

Marca: Briggs & Stratton

Model: Vanguard 520000

Categorie: Accesorii pentru autovehicule

Tip: Manualul proprietarului

English

bg cs hr slet hu

Èeština

lt lv pl ro ru

eesti keel Hrvatski Latviešu Polski Ðóññêèé

Românã

Áúëãàðñêè LietuviųMagyar Slovenšèina

Operator’s Manual

Èíñòðóêöèè çà åêñïëîàòàöèÿ

Návod k obsluze

Kasutusjuhend

Priruènik za operatora

Kezelési útmutató

Naudojimo instrukcija

Operatora rokasgrāmata

Instrukcja obs³ugi

Manual de utilizare

Ðóêîâîäñòâî ïî ýêñïëóàòàöèè

Priroènik za uporabo

Form No. 277110EST A

01999-B8006

E 2008 Briggs & Stratton C orporation,

Briggs & Stratton is a registered trademark

of Briggs & Stratton Corporation

Model 580000

Vanguardt

Turbocharged Diesel

Model 520000

580000

Vanguardt

Diesel

BRIGGSandSTRATTON.COM

4 BRIGGSandSTRATTON.COM

General Information

For replacement parts or technical assistance, record below the engine model, t ype, and

code numbers along with the date of purchase. These numbers are located on your

engine (see the Features and Controls page).

Date of purchase:

Engine model:

MM/DD/YYYY

Model: Code:Type:

Engine Power Rating I nformation

For 3/LC engines, gross power ratings are based on SAE J1995 criteria and net power

ratings are based on SAE J1349 criteria. Actual power output of production engines

installed in applications may vary depending on a number of factors, including the engine

RPM limit of the application, environmental conditions, engine/equipment maintenance,

and other variables.

Operator Safety

Explosion

Toxic Fumes

Moving Parts

Shock

Hot Surface

Kickback

Fire

Fuel Shutoff

Read Manual

Choke

Oil

Fuel

On Off

Stop

Wear Eye

Protection

Slow

Fast

SAFETY AND CONTROL SYMBOLS

Hazardous

Chemical

Frostbite

Hot Liquid or

Steam

The safety alert symbol

is used to identify safety information about hazards that can

result in personal injury. A signal word (DANGER, WARNING, or CAUTION) is used with the

alert symbol to indicate the likelihood and the potential severity of injury . In addition, a hazard

symbol may be used to represent the type of hazard.

DANGER indicates a hazard which, if not avoided, will result in death or

serious injury.

WARNING indicates a hazard which, if not avoided, could r esult in death or

serious injury.

CAUTION indicates a hazard which, if not avoided, might result in minor or

moderate injury.

CAUTION, when used without the alert symbol, indicates a situation t hat

could result in damage to the product.

The engine exhaust from this product contains chemicals k nown to

the State of California to cause cancer, birth defects, or other

reproductive harm.

WARNING

Briggs & Stratton does not approve or authorize the use of these

engines on 3-wheel All Terrain Vehicles (ATVs), motor bikes,

fun/ recreational go-karts, aircraf t products, or vehicles intended for

use in competitive events. Use of these engines in such applications

could result in property damage, serious injury (including paralysis),

or even death.

WARNING

CAUTION: This engine was shipped from Briggs & Stratton without oil. Before you start

the engine, make sure you add oil according to the instructions in this manual. If you

start the engine without oil, it will be damaged beyond repair and will not be covered

under warranty.

WARNING

Gasoline and its vapors are extremely flammable and explosive.

Fire or explosion can cause severe burns or death.

When Adding Fuel

• Turn engine off and let engine cool at least 2 minutes bef ore removing the fuel cap.

• Fill fuel tank outdoors or in well -ventilated area.

• Do not overfill fuel tank. Fill tank to approximately 1.5 inches (38 mm) below top of

neck to allow for fuel expansion.

• Keep gasoline away from s parks, open flames, pilot lights, heat, and other ignition

sources.

• Check fuel lines, tank, cap, and fittings frequently for cracks or leaks. Replace if

necessary

• If fuel spills, wait until it evaporates before starting engine.

When Starting Engine

• Ensure that spark plug, muffler, fuel cap and air cleaner (if equipped) are in place

and secured.

• Do not crank engine with spark plug removed.

• If engine floods, set choke (if equipped) to OPEN/RUN position, move throttle (if

equipped) to FAST position and crank until engine starts.

When Operating Equipment

• Do not tip engine or equipment at angle which causes gasoline to spill.

• Do not choke the carburetor to stop engine.

• Never start or run the engine with the air cleaner assembly (if equipped) or the air

filter (if equipped) removed.

When Changing Oil

• If you drain the oil from the top oil fill tube, the fuel tank must be empty or fuel can

leak out and result in a fire or explosion.

When Transporting Equipment

• Transport with fuel tank EMPTY or with fuel shut-off valve OFF.

When Storing Gasoline Or Equipment With Fuel In Tank

• Store away from furnaces, stoves, water heaters or other appliances that have pilot

light or other ignition source because they can ignite gasoline vapors.

Starting engine creates sparking.

Sparking can ignite nearby flammable gases.

Explosion and fire could result.

WARNING

• If there is natural or LP gas leakage in area, do not start engine.

• Do not use pressurized starting fluids because vapors are flammable.

Engines give off carbon monoxide, an odorless, colorless, poison gas.

Breathing carbon monoxide can cause nausea, fainting or death.

WARNING

• Start and run engine outdoors.

• Do not start or run engine in enclosed area, even if doors or windows are open.

Rotating parts can contact or entangle hands, feet, hair, clothing, or

accessories.

Traumatic amputation or severe laceration can result.

WARNING

• Operate equipment with guards in place.

• Keep hands and feet away from rotating parts.

• Tie up long hair and remove jewelry.

• Do not wear loose -fitting clothing, dangling drawstrings or items that could become

caught.

Running engines produce heat. Engine parts, especially muffler, become

extremely hot.

Severe thermal burns can occur on contact.

Combustible debris, such as leaves, grass, brush, etc. can catch fire.

WARNING

• Allow muffler, engine cylinder and fins to cool before touching.

• Remove accumulated debris from muffler area and cylinder area.

• Install and maintain in working order a spark arrester before using equipment on

forest-covered, grass-covered, brush-covered unimproved land. The state of

California requires this (Section 4442 of the California Public Resources Code).

Other states may have similar laws. Federal laws apply on federal land.

Severe thermal burns can occur by escaping steam or hot coolant.

WARNING

• DO NOT remove radiator cap or reservoir cap if engine is warm or running.

• Stop engine and allow it to cool before removing radiator cap or reservoir cap and

before changing or adding coolant.

Unintentional sparking can result in fire or electric shock.

Unintentional start-up can result in entanglement, traumatic amputation,

or laceration.

Fire hazard

WARNING

Before performing adjustments or repairs:

• Disconnect the spark plug wire and keep it away from the spark plug.

• Disconnect battery at negative terminal (only engines with electric start.)

• Use only correct tools.

• Do not tamper with governor spring, links or other parts to increase engine speed.

• Replacement parts must be the same and installed in the same position as the

original parts.

• Do not strike the flywheel with a hammer or hard object because the flywheel may

later shatter during operation.

When testing for spark:

• Use approved spark plug tester.

• Do not check f or spark with spark plug removed.

6 BRIGGSandSTRATTON.COM

Features and Controls

Compare the illustration

with your engine to familiarize yourself with the location of

various features and controls.

A. Engine Identification

Model Type Code

B. Engine Identification

Date Code

C. Glow Plug

D. Dipstick

E. Oil Fill

F. Oil Filter

G. Oil Drain Plug

H. Injector Nozzle

I. Electric Starter

J. Injector Pump

K. Thermostat

L. Turbocharger

M. Oil Pan

N. Alternator

O. Coolant Temperature Sending Unit

P. Fan

Q. Fan Belt

R. Exhaust Manifold

S. Oil Cooler (if equipped)

Operation

Oil capacity (see the Specifications section)

Oil Recommendations

We recommend the use of Briggs & Stratton Warranty Certified oils for best

performance. Other high-quality detergent oils are acceptable if c lassified for service CF

or CF-4. Do not use special additives.

Outdoor temperatures determine the proper oil viscosity for the engine. Use the chart to

select the best viscosity for the outdoor temperature range expected.

SAE 30

10W-30

Synthetic 5W-30

5W-30

°F °C

* Below 40°F(4°C) the use of SAE 30 will result in hard starting.

** Above 80°F(27°C) the use of 10W-30 may cause increased oil consumption. Check

oil level more frequently.

How To Check/Add Oil - Figure

2 4

Before adding or checking the oil

• Place engine level.

• Clean the oil fill area of any debris.

1. Remove the dipstick (A) and wipe with a clean cloth (Figure 2).

2. Completely insert the dipstick.

3. Remove the dipstick and check the oil level. It should be at the FULL mark (B)onthe

dipstick.

4. If low, remove the dipstick and add oil slowly into the engine oil fill (C). Do not

overfill.

Important: When adding oil, adequate venting is required as follows:

• Remove the dipstick.

• Make sure adequate clearance (D) is maintained between the oil fill device (E)

and the engine oil fill (C).SeeFigure4.

5. After adding oil, install the dipstick. Start and run engine at idle for five minutes. Shut

off engine. Wait three minutes and check oil level. If required, add oil to bring oil level

to the FULL mark (B) on the dipstick (Figure 2).

6. Install the dipstick.

Oil Pressure

If the oil pressure is too low, a pressure switch (if equipped) will either stop the engine or

activate a warning device on the equipment. If this occurs, stop the engine and check the

oil level with the dipstick.

If the oil level is below the ADD mark, add oil until it reaches the FULL mark. Start the

engine and check for proper pressure before continuing to operate.

If the oil level is between the ADD and FULL marks, do not start the engine. Contact

any Briggs & Stratton 3/LC Authorized Dealer to have the oil pressure problem

corrected.

Fuel Recommendations

Fuel must meet these requirements:

• This engine is certified to operate on diesel fuel. If incorrect fuel is used, black

smoke, power loss, and damage to the engine will occur, which will not be

covered by the warranty.

• Use clean, fresh diesel fuel with a minimum of 40 cetane. Fresh fuel prevents gum

from forming in the fuel system. Purchase fuel in a quantity that can be used within

30 days. See the Storage section.

CAUTION: Do not use kerosene or gasoline instead of diesel fuel. Failure to observe this

caution will damage the engine and void the engine warranty.

How To Add Fuel - Figure

WARNING

Fuel and its vapors are extremely flammable and explosive.

Fire or explosion can cause severe burns or death.

When Adding Fuel

• Turn engine off and let engine cool at least 2 minutes bef ore removing the fuel cap.

• Fill fuel tank outdoors or in well -ventilated area.

• Do not overfill fuel tank. Fill tank to approximately 1.5 inches (38 mm) below top of

neck to allow for fuel expansion.

• Keep fuel away from sparks, open flames, pilot lights, heat, and other ignition

sources.

• Check fuel lines, tank, cap, and fittings frequently for cracks or leaks. Replace if

necessary.

• If fuel spills, wait until it evaporates before starting engine.

1. Clean the fuel cap area of dirt and debris. Remove the fuel cap ( A, Figure 5).

2. Fill the fuel tank (B) with fuel. To allow for expansion of the fuel, do not fill above t he

bottom of the fuel tank neck (C).

3. Reinstall the fuel cap.

Coolant Recommendations

Coolant capacity (see t he equipment manufacture’s manual)

Important: This is a liquid-cooled engine. A 50/50% mixture of phosphate-free

antifreeze and tap water is required for cooling, rust resistance, and lubrication of the

water pump.

How To Check /Add Coolant

Severe thermal burns can occur by escaping steam or hot coolant.

WARNING

• DO NOT remove radiator cap or reservoir cap if engine is warm or running.

• Stop engine and allow it to cool before removing radiator cap or reservoir cap and

before changing or adding coolant.

1. Before operating, check the coolant level. The c oolant level must be between the

FULL and the LOW/ADD marks on the coolant reservoir. If the coolant level is low,

add a 50/50% coolant mixture of phosphate-free antifreeze and tap water to the

reservoir.

2. To remove the reservoir cap after engine is cool, place a thick cloth over the reservoir

cap. Slowly turn the reservoir cap counterclockwise to remove.

3. If the reservoir is dry, then add coolant to both the reservoir and to the radiator. See

the equipment manual for location, operation, and maintenance of the coolant

reservoir and the radiator.

4. To remove the radiator cap after engine is cool, place a thick cloth over t he radiator

cap. Slowly turn the radiator cap counterclockwise to the first stop. If pressurized

steam escapes from the cap, stand back to avoid injury. After all pressure is

released, push down and turn the radiator cap counterclockwise to remove.

Gauges And Lights

The gauges and lights shown are typical and represent various options that can be used.

See the equipment manual for location and operation of gauges and lights.

Coolant Temperature Gauge

Indicates coolant temperature when the electric start switch is in

the ON position.

Normal range 80º -- 9 0 º C (175º -- 195º F)

Dangerous range above 105º C (220º F)

Hour Meter Gauge

Indicates the total number of operating hours.

Fuel Gauge

Indicates the fuel remaining in the fuel tank. To minimize condensation,

keep the fuel tank full.

Temperature Light

If the temperature light comes on, the engine is overheating. Stop the

engine and check the coolant level (see the How To Check Coolant

section). Check t he radiator for debris that could restrict air flow.

Ignition Light

When the electric s tart switch is turned to the ON position, the ignition light

should be on. When the engine is running, the ignition light should go out.

If the ignition light is out when then electric startswitchintheONposition, check for a

blown fuse.

Engine Oil Pressure Light

When the electric start switch is turned to the ON position, the engine oil

pressure light should be on. When the engine is running, the engine oil

pressure light should go out. If the engine oil pressure light comes on when the engine

is running, immediately stop the engine. First, check the oil level (see the How To

Check/Add Oil section). Next, check the electrical system.

Charge Light

When the electric start switch is turned to the ON position, the charge light

should be on. When the engine is running, the charge light should go out.

If the c harge light comes on when the engine is running, check the electrical system.

Heat or Glow Light

When the ignition switch is turned to the heat/glow or the on position, the

glow light will indicate to indicate that the glow plugs are preheating the

combustion chamber.

Fuel Filter Light

The fuel filter light comes on when excess water has collected in the fuel

filter. The light should go out when the excess water is drained from the

fuel filter . If the fuel filter warning light illuminates while engine is running, stop the engine

and drain the water from the fuel filter.

How To Start The Engine - Figure

WARNING

Fuel and its vapors are extremely flammable and explosive.

Fire or explosion can cause severe burns or death.

When Starting Engine

• Ensure that muffler, fuel cap, and air cleaner are in place and secured.

• If engine floods, set choke (if equipped) to open/run position, move throttle (if

equipped) to fast position, and crank until engine starts.

• To prolong starter life, use short starting cycles, not to exceed 15 seconds per

minute. Extended cranking can damage the starter motor.

Engines give off carbon monoxide, an odorless, colorless, poison gas.

Breathing carbon monoxide can cause nausea, fainting or death.

WARNING

• Start and run engine outdoors.

• Do not start or run engine in enclosed area, even if doors or windows are open.

CAUTION: This engine was shipped from Briggs & Stratton without oil. Before you start

the engine, make sure you add oil according to the instructions in this manual. If you

start the engine without oil, it will be damaged beyond repair and will not be covered

under warranty.

CAUTION: Before starting the engine for the first time, charge the battery as

recommended by the equipment manufacturer. Failure to do so can cause damage to the

engine.

Note: Some engines and equipment have remote controls. See the equipment manual

for location and operation of remote controls.

1. Check the oil level. See the How To Check/Add Oil section.

2. Make sure equipment drive controls, if equipped, are disengaged.

3. Turn the fuel shut-off valve (A), if equipped, to the on position (Figure 6).

4. Move the throttle control (B) to the slow

position.

Note: For starting in cold weather (below -10º Cor14º F), move the throttle control to

the f ast

position.

5. Turn the electric start key (D) to the ON or HEAT position (Figure 6). The glow light

will indicate that the glow plugs are preheating t he combustion chamber.

6. When the glow light goes out, turn the electric start key to the START position.

CAUTION: To prolong starter life, use short starting cycles, not to exceed 15

seconds per minute. Extended cranking can damage the starter motor.

7. When the engine starts, release the key. The glow light will illuminate for about 20

seconds and then go out.

CAUTION: Do not accelerate or race a cold engine. Failure to observe this caution

can cause engine damage.

8. Allow the engine to run and warm up for several minutes before operating the

equipment.

How To Stop The Engine - Figure

1. Move the throttle control (B) to the slow position.

CAUTION: Before stopping a turbo-equipped engine, allow the engine to idle for one

minute to c ool the turbocharger. Failure to do so can damage the turbocharger.

2. Turn the key switch (D) to the off position (Figure 6). Remove the key and keep in a

safe place out of the reach of children.

3. After the engine stops, turn the fuel shut-off valve (A), if equipped, to the closed

position.

Maintenance

Use only original equipment replacement parts. Other parts may not perform as

well, may damage the unit, and may result in injury. In addition, use of other parts

may void your warranty.

We recommend that you see any Briggs & Stratton 3 /LC Authorized Dealer for all

maintenance and service of the engine and engine parts.

CAUTION: All the components used to build this engine must remain in place for proper

operation.

CAUTION: The manufacturer of the equipment on which this engine is installed specifies

the top speed at which the engine will be operated. Do not exceed this speed.

Emissions Control

Maintenance, replacement, or repair of the emissions control devices and systems

may be performed by any non-road engine repair establishment or individual.

However, to obtain “no charge” emissions control service, the work must be performed

by a factory authorized dealer. See the Emissions Warranty.

Unintentional start-up can result in entanglement, traumatic amputation,

or laceration.

Fire hazard

WARNING

Before performing adjustments or repairs:

• Disconnect battery at negative terminal (only engines with electric start.)

• Use only correct tools.

• Do not tamper with governor spring, links or other parts to increase engine speed.

• Replacement parts must be the same and installed in the same position as the

original parts.

• Do not strike the flywheel with a hammer or hard object because the flywheel may

later shatter during operation.

BRIGGSandSTRATTON.COM

Maintenance Chart

Every8HoursorDaily

• Check engine oil level

• Check coolant level

First 50 Hours (initial Break-In)

• Change engine oil *

Every 100 Hours

• Check fan belt tension

• Clean radiator

• Clean air filter

• Check muffler and clean spark arrestor (if equipped)

Every 150 Hours

• Change engine oil *

• Replace oil filter

Every 600 Hours or Annually

• Replace air filter

• Check valve clearance H

• Replace fuel filter

Every 1500 Hours

• Check injection nozzles z

Annually

• Change engine oil *

• Replace oil filter

• Change coolant

• Check fan belt tension

• Clean radiator

• Check muffler and clean spark arrestor (if equipped)

• Replace air filter

• Replace fuel filter

• Check valve clearance H

* Service more often when operating under heavy load or in high temperature.

Follow t he manufacturer’s maintenance schedule if non-Briggs & Stratton part is

used.

z Service must be performed by an authorized DENSO dealer.

H Not required unless engine performance problems are noted.

Inspect Muffler And Spark Arrester

Running engines produce heat. Engine parts, especially muffler, become

extremely hot.

Severe thermal burns can occur on contact.

Combustible debris, such as leaves, grass, brush, etc. can catch fire.

WARNING

• Allow muffler, engine cylinder and fins to cool before touching.

• Remove accumulated debris from muffler area and cylinder area.

• Install and maintain in working order a spark arrester before using equipment on

forest-covered, grass-covered, brush-covered unimproved land. The state of

California requires this (Section 4442 of the California Public Resources Code).

Other states may have similar laws. Federal laws apply on federal land.

Inspect the muffler for cracks, corrosion, or other damage. Remove the spark arrester, if

equipped, and inspect for damage or carbon blockage. If replacement parts are required,

make sure to use only original equipment replacement parts.

WARNING: Replacement parts must be the same and installed in the same

position as the original parts or fire could result.

How To Check Coolant

Important: This is a liquid cooled engine. A 50/50% coolant mixture of phosphate-free

antifreeze and tap water is required for cooling, rust resistance, and lubrication of the

water pump.

Severe thermal burns can occur by escaping steam or hot coolant.

WARNING

• DO NOT remove radiator cap or reservoir cap if engine is warm or running.

• Stop engine and allow it to cool before removing radiator cap or reservoir cap and

before changing or adding coolant.

1. Check the coolant level. The coolant level must be between the FULL and LOW, or

ADD, marks on the coolant reservoir. If the coolant level is low, add a 50/50%

coolant mixture of phosphate -free antifreeze and tap water to the reservoir.

2. To remove the reservoir cap after engine is cool, place a thick cloth over the reservoir

cap. Slowly turn the reservoir cap counterclockwise to remove.

3. If the reservoir is dry, add coolant to both the reservoir and to the radiator. See the

equipment manual for location, operation, and maintenance of the coolant reservoir

and of the radiator.

4. To remove the radiator cap after engine is cool, place a thick cloth over t he radiator

cap. Slowly turn the radiator cap counterclockwise to the first stop. If pressurized

steam escapes from the cap, stand back to avoid injury. After all pressure is

released, push down and turn the radiator cap counterclockwise to remove.

How To Change The Oil - Figure

2 3

CAUTION: Used oil is a hazardous waste product and must be disposed of properly. Do

not discard with household waste. Check with y our local authorities, service center, or

dealer for safe disposal/recycling facilities.

Remove Oil

1. Remove the oil drain plug (G, Figure 3). Drain the oil into an approved container.

2. After the oil has drained, install and tighten the oil drain plug.

Change The Oil Filter

For replacement intervals, see the Maintenance chart.

1. Drain the oil from the engine. See Remove Oil section.

2. Remove the oil filter (H, Figure 3) and dispose of properly.

3. Before you install the new oil filter, lightly lubricate the oil filter gasket with fresh,

clean oil.

4. Install the oil filter by hand until the gasket contacts the oil filter adapter, then tighten

theoilfilter1/2to3/4turns.

5. Add oil. See Add Oil section.

Add Oil

• Place engine level.

• Clean the oil fill area of any debris.

• See the Specifications section for oil capacity.

1. Remove the dipstick (A, Figure 2).

2. Pour the oil slowly into the engine oil fill (C). Do not overfill.

Important: When adding oil, adequate venting is required as follows:

• Remove the dipstick.

• Make sure adequate clearance (D) is maintained between the oil fill device (E)

and the engine oil fill (C).SeeFigure4.

3. After adding oil, install the dipstick. Start and run engine at idle for five minutes.

Check for leaks. Shut off engine. Wait three minutes and check oil level. If required,

add oil to bring oil level to the FULL mark (B) on the dipstick (Figure 2).

4. Install the dipstick.

How To Service The Air Filter - Figure

WARNING

Fuel and its vapors are extremely flammable and explosive.

Fire or explosion can cause severe burns or death.

• Never start or run the engine with the air cleaner assembly or the air filter removed.

CAUTION: Do not use pressurized air or solvents to clean the filter. Pressurized air can

damage the filter and solvents will dissolve the filter.

See the Maintenance Chart for service requirements.

1. Open the latches (A) and remove the cover (B).SeeFigure7.

2. Remove the air filter (C).

3. To loosen debris, gently tap the air filter on a hard surface. If the air filter is

excessively dirty, replace with a new air filter.

4. Install the air filter.

5. Install the cover and close the latches.

How To Replace The Fuel Filter - Figure

WARNING

Fuel and its vapors are extremely flammable and explosive.

Fire or explosion can cause severe burns or death.

• Disconnect battery at negative terminal (only engines with electric start.)

• Keep fuel away from sparks, open flames, pilot lights, heat, and other ignition

sources.

• Check fuel lines, tank, cap, and fittings frequently for cracks or leaks. Replace if

necessary.

• Before replacing the fuel filter, drain the fuel tank or close the fuel shut-off valve.

• Replacement parts must be the same and installed in the same position as the

original parts.

• If fuel spills, wait until it evaporates before starting engine.

If the fuel filter warning light illuminates while the engine is running, stop the engine and

drain water from fuel filter as follows:

Replace fuel filter

1. Disconnect the sensor wire (D).

2. Remove the drain plug (B) and discard the O-ring (E).

3. Remove the fuel filter (A) with a filter wrench.

4. Install a new fuel filter by hand until gasket (F) contacts the housing. Then tighten an

additional 1/3 turn.

5. Install the drain plug with new O-ring.

6. Connect the sensor wire.

7. Activate the primer pump (C) until resistance is felt.

8. Start the engine and check for leaks.

Drain water from fuel filter

1. Stop the engine.

2. Place a drain pan under the fuel filter (A) and loosen drain plug (B) approximately

one turn.

3. Water should drain from the fuel filter. If necessary, operate the primer pump (C)to

drain water, but only until fuel flows from the fuel filter.

4. Tighten the drain plug.

5. Start the engine. Make sure that the warning light is off. Check f or leaks.

How To Check/Adjust The Fan Belt - Figure

Check Fan Belt

1. Check the condition of the fan belt ( A, Figure 9). If the fan belt has cracks or is

damaged, replace with a new belt.

2. Check the tension of the fan belt. Press on the center (C) of the fan belt. If tension is

correct, the belt will move 3/8 -- 1/2 in (10 -- 12 mm) if 22 lbs (10 kg) of force is

applied to the center of the belt. If the tension is too loose, adjust as follows.

Adjust Fan Belt Tension

1. Loosen the alternator mounting bolts (D) and (E).SeeFigure9.

2. Position a pry bar ( F) against the alternator (G) and the side of t he engine block. To

tighten the fan belt, pull on the pry bar. Temporarily tighten the alternator mounting

bolts.

3. Check the tension of the fan belt. See Check Fan Belt section. If necessary, repeat

the procedure.

4. Tighten the alternator mounting bolts.

Torque bolt (D)to14ft-lbs(19Nm).

Torque bolt (E)to45ft-lbs(61Nm).

Storage

WARNING

Fuel and its vapors are extremely flammable and explosive.

Fire or explosion can cause severe burns or death.

When Storing Fuel Or Equipment With Fuel In Tank

• Store away from furnaces, stoves, water heaters or other appliances that have pilot

lights or other ignition sources because they can ignite fuel vapors.

Engine Oil

While the engine is still warm, change the engine oil.

Troubleshooting

Need Assistance? Go to BRIGGSandSTRATTON.COM or call 1-800-233-3723.

Specifications

Engine Specifications

Model 520000

Displacement 51.87 ci (850 cc)

Bore 2.677 in (68 mm)

Stroke 3.071 in (78 mm)

Oil Capacity 3.5 qt (3.3 L)

Engine Specifications

Model 580000

Displacement 58.09 ci (953 cc)

Bore 2.835 in (72 mm)

Stroke 3.071 in (78 mm)

Oil Capacity 3.5 qt (3.3 L)

Tune-up Specifications *

Model 520000, 580000

Intake Valve Clearance

0.008 in (0.2 mm)

Exhaust Valve Clearance

0.008 in (0.2 mm)

* Engine power will decrease 3.5% for each 1,000 feet (300 meters) above sea level and

1% for each 10° F(5.6° C) above 77° F(25° C). The engine will operate satisfactorily at

an angle up to 15°. Refer to the equipment operator’s manual for safe allowable

operating limits on slopes.

Check when engine is cold.

Common Service Parts n

Service Part Part Number

Air Filter 820263

Oil Filter 820314

Fuel Filter 820311

V-Belt (940 mm) 821075

V-Belt (970 mm) 820893

n We recommend that you see any Briggs & Stratton 3/LC Authorized Dealer for all

maintenance and service of the engine and engine parts. Use only genuine Briggs &

Stratton parts.

10 BRIGGSandSTRATTON.COM

BRIGGS & STRATTON 3/LC ENGINE OWNER WARRANTY POLICY

May 2008

Briggs & Stratton Corporation will repair or replace, free of charge, any part(s) of the engine that is defective in material or workmanship or both. Transportation charges on

product submitted for repair or replacement under this warranty must be borne by purchaser. This warranty is effective for and is subject to the time periods and conditions

stated below. For warranty service, f ind the nearest Authorized Briggs & Stratton 3 /LC Service Dealer in our dealer locator map at BRIGGSandSTRATTON.COM, or

by calling 1-800-233-3723, or as listed in the ‘Yellow Pagest’.

There is no other expressed warranty. Implied warranties, including those of merchantability and fitness for a particular purpose, are limited to one year from

purchase, or to the extent permitted by law and all implied warranties are excluded. Liability for incidental or consequential damages are excluded to the extent

exclusion i s permitted by law. Some states or countries do not allow limitations on how long an implied warranty lasts, and some states or countries do not allow the

exclusion or limitation of incidental or consequential damages, so the above limitation and exclusion may not apply to you. This warranty gives you specific legal rights and

you may also have other rights which vary from state to state and country to country.

LIMITED WARRANTY

OUR PRODUCT

Warranty Period

Vanguardt 3/LC

Major Parts Warranty * Parts & Labor *

Consumer and Commercial Use

2 years

3 years 2 years

* Note the following special warranty periods: For purposes of this warranty policy, Parts & Labor coverage is 2 years. Major parts only coverage is extended through

the third year of operation. Major Parts Warranty (M.P.W.) covers but is not limited to or exclusive to cylinder block, cylinder head, crankshaft, camshaft, gears, pistons,

rods, flywheel, flywheel housing, oil pump, fan, pulleys, mechanical governor, intake manifold, and oil pan. M.P.W. does not cover and is not limited to piston rings,

replaceable bearings, water pump, any electrical component, valve train components, accessory parts, seals, gaskets, carburetors, exhaust manifold, hoses, all fuel

system components, injectors, injector pump, turbocharger, muffler, any filters, radiator, thermostat, spark plugs, glow plugs, and fuel transfer pumps. The warranty period

begins on the date of purchase by the first retail consumer or commercial end user and continues for the period of t ime stated in the table above.

No warranty registration is necessary to obtain warranty on Briggs & Stratton products. Save your proof of purchase receipt. If you do not provide proof of the initial

purchase date at the time warranty service is requested, the manufacturing date of the product will be used to determine the warranty period.

About Your Warranty

Briggs & Stratton welcomes warranty repair and apologizes to you for being

inconvenienced. Any Authorized Briggs & Stratton 3/LC Service Dealer may perform

warranty repairs. Most warranty repairs are handled routinely, but sometimes requests

for warranty service may not be appropriate. For example, warranty would not apply if

engine damage occurred because of misuse, lack of routine maintenance, shipping,

handling, warehousing or improper installation. Similarly, warranty is void if the serial

number of the engine has been removed or the engine has been altered or modified.

If a customer differs with the decision of the Service Dealer, an investigation will be made

to determine whether the warranty applies. Ask the Service Dealer to submit all

supporting facts t o his Distributor or the Factory for review. If the Distributor or the

Factory decides that the claim is justified, the customer will be fully reimbursed for those

items that are defective. To avoid misunderstanding which might occur between the

customer and the Dealer, listed below are some of the causes of engine failure that the

warranty does not cover.

Normal wear: Engines, like all mechanical devices, need periodic parts service and

replacement to perform well. Warranty will not cover repair when normal use has

exhausted the life of a part or an engine. Warranty would not apply if engine damage

occurred because of misuse, lack of routine maintenance, shipping, handling,

warehousing or improper installation. Similarly, warranty is void if the serial number of the

engine has been removed or the engine has been altered or modified.

Improper maintenance: The life of an engine depends upon the conditions under which

it operates, and the care it receives. Some applications, such as tillers, pumps and rotary

mowers, are very often used in dusty or dirty conditions, which can cause what appears

to be premature wear. Such wear, when caused by dirt, dust, spark plug cleaning grit, or

other abrasive material that has entered the engine because of improper maintenance, is

not covered by warranty.

This warranty covers engine related defective material and/or workmanship only

and not replacement or refund of the equipment to which the engine may be

mounted. Nor does the warranty extend to repairs required because of:

1 Engines that are not properly applied to equipment. It is s trongly recommended that

the factory be contacted prior to applying a B&S 3/LC engine to equipment that did

not originally use a B&S 3/LC engine.

2 Problems caused by parts that are not original Briggs & Stratton parts.

3 Equipment controls or installations that prevent starting, cause unsatisfactory engine

performance, or shorten engine life. (Contact equipment manufacturer.)

4 Leaking carburetors, clogged fuel pipes or injectors, sticking valves, contaminated

injector pumps, or other damage, caused by using contaminated or stale fuel. Use

clean, fresh fuel (lead free gasoline, diesel fuel) and Briggs & Stratton fuel stabilizer,

Part No. 5041.

5 Parts which are scored or broken because an engine was operated with insufficient

or contaminated lubricating oil, or an incorrect grade of lubricating oil (Check oil level

daily or after every 8 hours of operation. Refill when necessary and change oil and

oil filter at recommended intervals). OIL GARD may not shut down running engine.

Engine damage may occur if oil level is not properly maintained. Read Operator’s

Manual.

6 Repair or adjustment of associated parts or assemblies such as clutches,

transmissions, remote controls, etc., which are not manufactured by Briggs &

Stratton.

7 Damage or wear to parts caused by dirt, which entered the engine because of

improper air c leaner maintenance, re-assembly, or use of a non -original air cleaner

element or cartridge. At recommended intervals, clean and/or replace the filter as

stated in the Operator’s Manual.

8 Parts damaged by over-speeding, or overheating caused by grass, debris, or dirt,

which plugs, clogs radiator or air cooling access openings,or damage caused by

operating the engine in a confined area without sufficient ventilation. Engine damage

caused by not using accurate mix of anti-freeze and tap water, or water entering the

engine due to any cause.

9 Engine or equipment parts broken by excessive vibration caused by a loose engine

mounting, loose cutter blades, unbalanced blades or loose or unbalanced impellers,

improper attachment of equipment to engine crankshaft, over-speeding or other

abuse in operation.

10 Routine tune-up or adjustment of the engine.

11 Engine or engine component failure, i.e., combustion chamber, valves, valve seats,

valve guides, or burned starter motor windings, caused by the use of alternate fuels

such as, liquified petroleum, natural gas, altered gasolines, etc.

W arranty service is available only through authorized service dealers by Briggs &

Stratton Corporation. Locate your nearest Authorized Briggs & Stratton 3/LC

Service Dealer in our dealer locator map on BRIGGSandSTRA TT ON.COM or by

calling 1-800-233-3723, or as listed in the ‘Y ellow Pagest’.

Emission Control System Warranty Statement and Warranted Parts

Briggs & Stratton Corporation (B&S), the California Air Resources Board (CARB) and the United States Environmental Protection

Agency (U.S. EPA) Emission Control System Warranty Statement (Owner’s Warranty Rights and Obligations)

Emissions control warranty coverage is applicable to certified model year 2007 and later engines, which are purchased and used

in California, and to certified model year 2007 and later engines, which are purchased and used elsewhere in the United States.

California and United States Emission Control Warranty Statement

The California Air Resources Board (CARB), U.S. EPA and B&S are pleased to explain

the Emission Control System Warranty on your model year 2007 and later off-road

spark-ignition engine over 19kW (25HP). In California, new off-road large spark-ignition

engines must be designed, built and equipped to meet the State’s stringent anti-smog

standards. Elsewhere in the United States, new Non-road spark-ignition engines over

19kW c ertified for model year 2007 and later, must meet similar standards set forth by

the U.S. EPA. B&S must warrant the emission control system on your engine for the

period of time listed below, provided there has been no abuse, neglect or improper

maintenance of your engine.

Your emission control system includes parts such as the carburetor or fuel injection

system, the air cleaner, ignition system, muffler, and catalytic converter. Also included

may be hoses, belts, connectors and other emission related assemblies.

Where a warrantable condition exists, B&S will repair your engine at no cost to you

including diagnosis, parts and labor.

Briggs & Stratton Emission Control Warranty Coverage

The 2007 and later off-road spark-ignition engines are warranted for two years.

If any emission-related part on your engine is defective, the part will be repaired or

replaced by B&S.

Owner’s Warranty Responsibilities

As the engine owner, you are responsible for the performance of the required

maintenance listed in your Operating & Maintenance Instructions . B&S recommends that

you retain all your receipts covering maintenance on your engine, but B&S cannot deny

warranty s olely for the lack of receipts or for your failure to ensure the performance of all

scheduled maintenance.

As the engine owner, you should however be aware that B&S may deny you warranty

coverage if your engine or a part has failed due to abuse, neglect, improper maintenance

or unapproved modifications. You are responsible for presenting your engine to an

Authorized B&S Service Dealer as soon as a problem exists. The warranty repairs

should be completed in a reasonable amount of time, not to exceed 30 days. If you have

questions regarding your warranty rights and responsibilities, you should contact a B&S

Service Representative at 1 -800-233-3723.

EMISSION COMPLIANCE PERIOD: 1000 HOURS

Briggs & Stratton Corporation Emission Control Warranty Provisions

The following are specific provisions relative to your Emission Control Warranty Coverage. It is in addition to the B&S engine warranty for non-regulated engines found in the

Operating & Maintenance Instructions.

1. Warranted Parts

Coverage under this warranty extends only to the parts listed below (the emission

control systems parts) to the extent these parts were present on the engine

purchased.

a. Fuel Metering System

• Carburetor and internal parts (if applicable)

• Cold start enrichment system (if applicable)

• Fuel injection system (if applicable)

• Air/ fuel ratio feedback control system (if applicable)

• Fuel pump

• Fuel filter

b. Air Induction System

• Air cleaner

• Intake manifold

• Throttle body (if applicable)

c. Ignition System

• Spark plug

• Ignition coil

• Ignition processor (if applicable)

d. Exhaust System

• Exhaust manifold (if applicable)

e. Catalyst System

• Catalytic converter (if applicable)

f. Miscellaneous Items Used in Above System

• Pressure, temperature, position, speed sensitive devices

• Electronic controls

• Connectors and assemblies

• Hoses

2. Length of Coverage

B&S warrants to the initial owner and each subsequent purchaser that the

Warranted Parts shall be free from defects in materials and workmanship which

caused the failure of the Warranted Parts for a period of two years from the date the

engine is delivered to a retail purchaser.

3. No Charge

Repair or replacement of any Warranted Part will be performed at no charge to the

owner, including diagnostic labor which leads to the determination that a Warranted

Part is defective, if the diagnostic work is performed at an Authorized B&S Service

Dealer. For emission warranty service, contact your nearest Authorized B&S

Service Dealer as listed in the “Yellow Pages” under “Engines, Gasoline,” “Gasoline

Engines” “Lawn Mowers,” or similar category.

4. Claims and Coverage Exclusions

Warranty claims shall be filed in accordance with the provisions of the B&S Engine

Warranty Policy. Warranty coverage shall be excluded for failures of Warranted

Parts which are not original B&S parts or because of abuse, neglect or improper

maintenance as set forth in the B&S Engine Warranty Policy. B&S is not liable to

cover failures of Warranted Parts caused by the use of add-on, non-original, or

modified parts.

5. Maintenance

Any Warranted Part which is not scheduled for replacement as required

maintenance or which is scheduled only for regular inspection to the effect of “repair

or replace as necessary” shall be warranted as to defects for the warranty period.

Any Warranted Part which is scheduled for replacement as required maintenance

shall be warranted as to defects only for the period of time up to the first scheduled

replacement for that part. Any replacement part that is equivalent in performance

and durability may be used in the performance of any maintenance or repairs. The

owner is responsible for the performance of all required maintenance, as defined in

the B&S Operating & Maintenance Instructions.

6. Consequential Coverage

Coverage hereunder shall extend to the failure of any engine components caused

by the failure of any Warranted Part still under warranty.

12 BRIGGSandSTRATTON.COM

Îáùà èíôîðìàöèÿ

Çà ˜åçå˜âíè …àñòè èëè òåõíè…åñêà ïîìîù çàïèμåòå ïî-äîëó ìîäåëà, âèäà è

êîäîâåòå íà äâèãàòåë ñ äàòàòà íà êóïóâàíåòî ìó. ‚åçè êîäîâå ñå íàìè˜àò âú˜õó

âàμè äâèãàòåë. (âè¥òå ñò˜àíèöàòà Åëåìåíòè è óïðàâëåíèÿ).

Äàòà íà êóïóâàíå:

Ìîäåë íà äâèãàòåëÿ:

MM/ÄÄ/øøøø

ﬂîäåë: ÿîä:‚èï:

Èíôîðìàöèÿ çà íîìèíàëíàòà ìîùíîñò íà äâèãàòåëèòå

Çà äâèãàòåëèòå 3/LC (ò˜è öèëèíä˜îâè ñ âîäíî îõëà¥äàíå) ïúëíàòà ìîùíîñò ñå

îñíîâàâà íà ê˜èòå˜èèòå ñúãëàñíî ﬁ˜àâèëíèêà J1995 íà SAE (Ä˜ó¥åñòâîòî íà

èí¥åíå˜èòå îò àâòîìîáèëíàòà ï˜îìèμëåíîñò è ò˜àíñïî˜òà), à ïîëåçíàòà ìîùíîñò

- ñúãëàñíî ê˜èòå˜èèòå îò J1349 íà SAE. ﬁîëåçíàòà ï˜îèçâîäñòâåíà ìîùíîñò íà

äâèãàòåëè, ìîíòè˜àíè çà ˜àçëè…íè ï˜èëî¥åíè, ìî¥å äà âà˜è˜à â çàâèñèìîñò îò

ãîëì á˜îé ôàêòî˜è, âêë˚…èòåëíî ã˜àíè…íèòå îáî˜îòè íà ï˜èëî¥íè ìåõàíèçúì,

óñëîâèòà íà îêîëíàòà ñ˜åäà, ïîää˜ú¥êàòà íà äâèãàòåë/îáî˜óäâàíåòî è ä˜óãè

ï˜îìåíëèâè.

Òåõíèêà çà áåçîïàñíîñò íà îïåðàòîðà

Âçðèâîîïàñíî

Îòðîâíè

ãàçîâå

Äâèæåùè

ñå ÷àñòè

Îïàñíîñò çà ïîðàæåíèÿ

îò åëåêòðè÷åñêè òîê

Ãîðåùà

ïîâúðõíîñò

Îáðàòåí

óäàð

Îãíåîïàñíî

Ïðåêðàòÿâàíå

ïîäàâàíåòî íà ãîðèâî

Ïðî÷åòåòå

Ðúêîâîäñòâîòî

Ñìóêà÷

Ìàñëî

Ãîðèâî

Âêë. Èçêë.

Ñòîï

Äà ñå íîñÿò

ïðåäïàçíè î÷èëà

Áúðçè

îáîðîòè

Áàâíè

îáîðîòè

ÑÈÌÂÎËÈ ÇÀ ÁÅÇÎÏÀÑÍÎÑÒ È ÓÏÐÀÂËÅÍÈÅ

Îïàñíè

õèìèêàëè

Îïàñíîñò îò

èçìðúçâàíå

Ãîðåùà òå÷íîñò

èëè ïàðà

ﬁ˜åäóï˜åäèòåëíèò ñèìâîë çà îïàñíîñò

îï˜åäåë ï˜åäîõ˜àíèòåëíà

èíôî˜ìàöè çà ˜èñêîâå, êîèòî ìîãàò äà äîâåäàò äî íà˜àíâàíå íà ïå˜ñîíàëà.

Ñèãíàëèçè˜àùà äóìà (›ﬁæÑ‹›, ﬁˆÅÄ‡ﬁˆÅ≠ÄÅ‹¤Å èëè ◊‹¤ﬂæ‹¤Å) ñå ïîñòàâ

çàåäíî ñ ï˜åäóï˜åäèòåëåí ñèìâîë, çà äà ïîñî…è âå˜îòíîñòòà è ïîòåíöèàëíàòà

ñå˜èîçíîñò íà íà˜àíâàíåòî. Äîïúëíèòåëíî, åäèí ñèìâîë çà îïàñíîñò ìî¥å äà

ïîêàçâà âèäà íà îïàñíîñòòà.

ÎÏÀÑÍÎ ïîñî…âà îïàñíîñò, êîòî, àêî íå áúäå èçáåãíàòà, ùå äîâåäå

äî ñìúðò èëè ñåðèîçíî íàðàíÿâàíå.

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ ïîñî…âà îïàñíîñò, êîòî, àêî íå áúäå

èçáåãíàòà, ìîæå äà äîâåäå äî ñìúðò èëè ñåðèîçíî íàðàíÿâàíå.

ÂÍÈÌÀÍÈÅ ïîñî…âà îïàñíîñò, êîòî, àêî íå áúäå èçáåãíàòà, ìîæå äà

äîâåäå äî ìàëêà èëè ñðåäíà ñòåïåí íà íàðàíÿâàíå.

ÂÍÈÌÀÍÈÅ, èçïîëçâàíî áåç ï˜åäóï˜åäèòåëíè ñèìâîë, ïîñî…âà

ñèòóàöè,êîòî áè ìîãëà äà äîâåäå äî ïîâðåæäàíå íà ïðîäóêòà.

¤çãî˜åëèòå ãàçîâå îò òîçè äâèãàòåë ñúäú˜¥àò õèìè…åñêè

ñúåäèíåíè, èçâåñòíè íà ùàòà ÿàëèôî˜íè êàòî ï˜è…èíèòåëè íà

˜àê, óâ˜å¥äàíè ï˜è ˜à¥äàíå, èëè ä˜óãè óâ˜å¥äàíè, ñâú˜çàíè

ñ ˜åï˜îäóêòèâíîñòòà.

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ

ÿî˜ïî˜àöè Briggs & Stratton íå îäîá˜âàèíåïîçâîëâà

èçïîëçâàíåòî íà òåçè äâèãàòåëè âú˜õó âñúäåõîäè íà 3 êîëåëà,

ìîòîöèêëåòè, óâåñåëèòåëíè/êîëè…êè çà êà˜òèíã, ëåòàòåëíè

àïà˜àòè èëè ò˜àíñïî˜òíè ñ˜åäñòâà çà ó…àñòèå â ñúñòåçàòåëíè

ìå˜îï˜èòè. ¤çïîëçâàíåòî íà òåçè äâèãàòåëè íà òàêèâà

ìàμèíè ìî¥å äà äîâåäå äî ìàòå˜èàëíè ùåòè, ñå˜èîçíè

íà˜àíâàíè (âêë˚…èòåëíî ïà˜àëèçà) è äî˜è äî ñìú˜ò.

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ

ÂÍÈÌÀÍÈÅ: ‹àñòîùèò äâèãàòåë ñå äîñòàâ îò Briggs & Stratton áåç ìàñëî.

ﬁ˜åäè äà ñòà˜òè˜àòå äâèãàòåë ñå óâå˜åòå, …å ñòå íàëåëè ìàñëî â íåãî ñïî˜åä

èíñò˜óêöèèòå â òîâà ˜úêîâîäñòâî. æêî ãî ñòà˜òè˜àòå áåç ìàñëî, ò îé ùà ñå

ïîâ˜åäè áåç äà áúäå âúçìî¥íî äà ñå ˜åìîíòè˜à è ãà˜àíöèòà íìà äà ïîê˜èâà

ùåòàòà.

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ

Áåíçèíúò è íåãîâèòå ïàðè ñà èçêëþ÷èòåëíî îãíåîïàñíè è

èçáóõëèâè.

Ïîæàð èëè âçðèâ ìîãàò äà ïðè÷èíÿò ñåðèîçíè îáãàðÿíèÿ èëè

ñìúðò.

Ïðè äîëèâàíå íà ãîðèâî

• ¤çêë˚…åòå äâèãàòåë è ãî îñòàâåòå äà ñå îõëàäè íàé-ìàëêî 2 ìèíóòè, ï˜åäè

äà ñâàëèòå êàïà…êàòà íà ˜åçå˜âîà˜à çà ãî˜èâî.

• ﬁúëíåòå ˜åçå˜âîà˜à çà ãî˜èâî íà îòê˜èòî èëè â äîá˜å âåíòèëè˜àíî

ïîìåùåíèå.

• ‹å ï˜åïúëâàéòå ˜åçå˜âîà˜à çà ãî˜èâî. ﬁúëíåòå ãî ï˜èáëèçèòåëíî 1,5 èí…à

(38 mm) ïî-íèñêî îò ãî˜íè ˜úá íà ãú˜ëîâèíàòà, çà äà ïîçâîëèòå ˜àçμè˜åíèå

íà ãî˜èâîòî.

• Ä˜ú¥òå áåíçèíà äàëå… îò èñê˜è, îòê˜èòè ïëàìúöè, ñèãíàëíè ëàìïè, òîïëèíà

è ä˜óãè çàïàëèòåëíè èçòî…íèöè.

• ﬁ˜îâå˜âàéòå …åñòî ãî˜èâîï˜îâîäèòå, ˜åçå˜âîà˜à, êàïà…êàòà è

ñúåäèíåíèòà çà ïóêíàòèíè èëè òå…îâå. Çàìåíåòå ãè, àêî å íåîáõîäèìî

• æêî ãî˜èâîòî ñå ˜àçëåå, èç…àêàéòå äîêàòî òî ñå èçïà˜è, ï˜åäè äà ñòà˜òè˜àòå

äâèãàòåë.

Ïðè ñòàðòèðàíå íà äâèãàòåëÿ

• ‡âå˜åòå ñå, …å çàïàëèòåëíàòà ñâåù, μóìîçàãëóμèòåë, êàïà…êàòà íà

˜åçå˜âîà˜à çà ãî˜èâî è âúçäóμíè ôèëòú˜ (àêî èìà òàêúâ) ñà íà ìñòîòî ñè è

ñà îáåçîïàñåíè.

• ‹å ˜àçâú˜òàéòå äâèãàòåë ñ èçâàäåíà çàïàëèòåëíà ñâåù.

• æêî äâèãàòåëò ñå çàäàâè, ïîñòàâåòå ñìóêà…à (àêî èìà òàêúâ) íà ïîçèöè

OPEN/RUN, ï˜èäâè¥åòå ˜ú…íàòà ãàç (àêî èìà òàêàâà) íà ïîçèöè FAST è

˜àçâú˜òàéòå, äîêàòî äâèãàòåëò ñòà˜òè˜à.

Ïðè ðàáîòåùà ìàøèíà

• ‹å íàêëàíéòå äâèãàòåë èëè ìàμèíàòà ïîä úãúë, êîéòî âîäè äî ˜àçëèâàíå íà

áåíçèíà.

• ‹å çàïóμâàéòå êàìå˜àòà íà êà˜áó˜àòî˜à, çà äà ñï˜åòå äâèãàòåë.

• ‹èêîãà íå ñòà˜òè˜àéòå è íå ˜àáîòåòå ñ äâèãàòåë ï˜è äåìîíòè˜àí êîìïëåêò

íà âúçäóμ

íè ôèëòú˜ (àêî èìà òàêúâ) èëè ñàìî âúçäóμåí ôèëòú˜ (àêî èìà

òàêúâ).

Ïðè ñìåíÿâàíå íà ìàñëî

• æêî èçòî…âàòå ìàñëîòî îò ãî˜íàòà ò˜úáà çà ïúëíåíå ñ ìàñëî, ˜åçå˜âîà˜úò çà

ãî˜èâî ò˜áâà äà áúäå ï˜àçåí, èëè òî ìî¥å äà ïîòå…å è äà ï˜è…èíè ïî¥à˜ èëè

åêñïëîçè.

Ïðè òðàíñïîðòèðàíå íà ìàøèíàòà

• ‚˜àíñïî˜òè˜àéòå ñ ﬁˆæÇÅ‹ ˜åçå˜âîà˜, èëè ñ ê˜àí çà ïîäàâàíå íà ãî˜èâî íà

ïîçèöè OFF.

Êîãàòî ñêëàäèðàòå áåíçèí èëè îáîðóäâàíå ñ ãîðèâî â ðåçåðâîàðà

• Ñêëàäè˜àéòå äàëå… îò ïåùè, ïå…êè, âîäîíàã˜åâàòåëè èëè ä˜óãè åëåêò˜è…åñêè

ï˜èáî˜è, êîèòî èìàò ñèãíàëíà ëàìïà èëè ä˜óã çàïàëèòåëåí èçòî…íèê, çàùîòî

òå ìîãàò äà âúçïëàìåíò áåíçèíîâèòå ïà˜è.

Ïóñêàíåòî íà äâèãàòåëÿ ñúçäàâà èñêðåíå.

Èñêðåíåòî ìîæå äà âúçïëàìåíè íàìèðàùèòå ñå íàîêîëî

çàïàëèìè ãàçîâå.

Òîâà ìîæå äà äîâåäå äî åêñïëîçèÿ è ïîæàð.

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ

• æêî èìà èçòè…àíå íà ï˜è˜îäåí èëè âòå…íåí ãàç ï˜îïàí â ïîìåùåíèåòî, íå

ñòà˜òè˜àéòå äâèãàòåë.

• ‹å èçïîëçâàéòå ãî˜èâà çà íà…àëíî çàïàëâàíå ïîä íàëãàíå, çàùîòî ïà˜èòå èì

ñà çàïàëèòåëíè.

Äâèãàòåëèòå èçïóñêàò âúãëåðîäåí îêèñ, êîéòî å îòðîâåí ãàç, áåç

ìèðèñ è öâÿò.

Âäèøâàíåòî íà âúãëåðîäåí îêèñ ìîæå äà ïðè÷èíè ãàäåíå,

ïðèïàäúê èëè ñìúðò.

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ

• Ñòà˜òè˜àéòå è ˜àáîòåòå ñ äâèãàòåë íàâúí.

• ‹å ñòà˜òè˜àéòå è íå ˜àáîòåòå ñ äâèãàòåë â çàòâî˜åíî ïîìåùåíèå, äî˜è è ï˜è

îòâî˜åíè â˜àòè èëè ï˜îçî˜öè.

Âúðòÿùèòå ñå ÷àñòè ìîãàò äà äîïðàò èëè çàõâàíàò ðúöå, êðàêà, êîñà,

îáëåêëî èëè ïðèíàäëåæíîñòè.

Ìîæå äà ñå äîñòèãíå äî òðàâìàòè÷íà àìïóòàöèÿ èëè ñåðèîçíî

íàðàíÿâàíå.

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ

• ˆàáîòåòå ñ äâèãàòåë ï˜è ïîñòàâåíè çàùèòíè êàïàöè.

• Ä˜ú¥òå ˜úöåòå è ê˜àêàòà ñè äàëå… îò âú˜òùè ñå …àñòè.

• ﬁ˜èâú˜çâàéòå äúëãèòå êîñè è ñâàëéòå óê˜àμåíèòà.

• ‹å íîñåòå ïî ñåáå ñè μè˜îêî îáëåêëî, âèñùè μíó˜îâå èëè âåùè, êîèòî ìîãàò

äà áúäàò çàõâàíàòè.

Ðàáîòåùèòå äâèãàòåëè îòäåëÿò òîïëèíà. ×àñòèòå íà äâèãàòåëèòå,

îñîáåíî øóìîçàãëóøèòåëÿ, ñòàâàò èçêëþ÷èòåëíî ãîðåùè.

Ïðè äîïèð ìîæå äà ïîëó÷èòå ñåðèîçíî èçãàðÿíå.

Ãîðèìèòå îòïàäúöè, êàòî ëèñòà, òðåâè, õðàñòàëàê è äðóãè, ìîãàò äà

ñå çàïàëÿò.

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ

• ›ñòàâåòå μóìîçàãëóμèòåë, öèëèíäú˜à íà äâèãàòåë è ˜åá˜àòà äà ñå

îõëàäò, ï˜åäè äà ãè äîêîñâàòå.

• ›òñò˜àíåòå íàò˜óïàíèòå îòëîìêè îêîëî μóìîçàãëóμèòåë è öèëèíäú˜à.

• ﬂîíòè˜àéòå è ïîääú˜¥àéòå â ˜àáîòíî ñúñòîíèå èñê˜îãàñèòåë, ï˜åäè äà

èçïîëçâàòå äâèãàòåë íà çàëåñåíè ìåñòà, çàò˜åâåíè ïëîùè, ïëîùè ñ õ˜àñòè è

íåîá˜àáîòåíè ìåñòà. Âàòúò ÿàëèôî˜íè èçèñêâà òîâà (â ˆàçäåë 4442 íà

ÿàëèôî˜íèéñêè ï˜àâèëíèê çà îáùåñòâåíè ˜åñó˜ñè). ◊úçìî¥íîåä˜óãèùàòè

äà èìàò ïîäîáíè çàêîíè. ·åäå˜àëíèòå çàêîíè ñå ï˜èëàãàò íà ôåäå˜àëíà

òå˜èòî˜è.

Ìîãàò äà ñå ïîëó÷àò ñåðèîçíè èçãàðÿíèÿ îò îñâîáîæäàâàùàòà ñå

ïàðà èëè îò ãîðåùàòà îõëàæäàùà òå÷íîñò.

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ

• ‹Å Ñ◊æ⁄ßÉ‚Å êàïà…êèòå îò ˜àäèàòî˜à èëè ˜åçå˜âîà˜à, àêî äâèãàòåëòå

ãî˜åù èëè ˜àáîòè.

• Ñï˜åòå äâèãàòåë è ãî îñòàâåòå äà ñå îõëàäè, ï˜åäè ñà ñâàëíå êàïà…êèòå íà

˜àäèàòî˜à èëè ˜åçå˜âîà˜à è ï˜åäè ñìíàòà èëè íàëèâàíåòî íà îõëà¥äàùàòà

òå…íîñò.

Ñëó÷àéíî èñêðåíå ìîæå äà äîâåäå äî ïîæàð èëè ïîðàçÿâàíå îò

åëåêòðè÷åñêè òîê.

Íåâîëíî ñòàðòèðàíå ìîæå äà äîâåäå äî çàõâàùàíå, òðàâìàòè÷íà

àìïóòàöèÿ èëè äî ðàíÿâàíå.

Îïàñíîñò îò ïîæàð

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ

Ïðåäè èçâúðøâàíå íà ðåãóëèðîâêè è ïîïðàâêè:

• ›òêà…åòå êàáåëà íà çàïàëèòåëíàòà ñâåù è ãî ä˜ú¥òå äàëå… îò íå.

• ›òêà…åòå ìèíóñ-êëåìàòà íà àêóìóëàòî˜à (ñàìî ï˜è äâèãàòåëè ñ åëåêò˜è…åñêè

ñòà˜òå˜).

• ¤çïîëçâàéòå ñàìî ïîäõîäùè èíñò˜óìåíòè.

• ‹å çàñòîïî˜âàéòå ñ ˜åãóëè˜àùàòà ï˜ó¥èíà, ëîñòîâèòå ñèñòåìè èëè ñ ä˜óãè

…àñòè, çà äà ïîâèμèòå îáî˜îòèòå íà äâèãàòåë.

• ˆåçå˜âíèòå …àñòè ò˜áâà äà áúäàò ñúñ ñúùîòî êà…åñòâî è äà ñå ìîíòè˜àò â

ñúùàòà ïîçèöè, êàêòî î˜èãèíàëíèòå …àñòè.

• ‹å óä˜éòå ìàõîâèêà ñ …óê èëè òâú˜ä ï˜åäìåò, çàùîòî òîé ìî¥å äà ñå ñò˜îμè

ïî â˜åìå íà ˜àáîòà.

Ïðè èçïðîáâàíå çà èñêðà:

• ¤çïîëçâàéòå îäîá˜åí òèï òåñòå˜ çà ñâåùè.

• ‹å ï˜àâåòå ï˜îâå˜êà çà èñê˜à ï˜è èçâàäåíà çàïàëèòåëíà ñâåù.

14 BRIGGSandSTRATTON.COM

Åëåìåíòè è óïðàâëåíèÿ

Ñ˜àâíåòå èë˚ñò˜àöèòà

ñâàμè äâèãàòåë, çà äà ñå çàïîçíàåòå ñ

˜àçïîëî¥åíèåòî íà ˜àçëè…íèòå åëåìåíòè è óï˜àâëåíè.

A. ﬂà˜êè˜îâêà íà äâèãàòåë

Ìîäåë Òèï Êîä

B. ﬂà˜êè˜îâêà íà äâèãàòåë

Äàòà Êîä

C. ﬁîäã˜âàùà ñâåù

D. ‹èâîïîêàçàòåë

E. ›òâî˜ çà íàëèâàíå íà ìàñëî

F. ﬂàñëåí ôèëòú˜

G. ﬁ˜îáêà çà èçòî…âàíå íà ìàñëîòî

H. Ä˚çà çà âï˜úñêâàíå íà ãî˜èâîòî

I. Åëåêò˜è…åñêè ñòà˜òå˜

J. øî˜èâî-íàãíåòàòåëíà ïîìïà

K. ‚å˜ìîñòàò

L. ‚ó˜áîêîìï˜åñî˜

M. ÿà˜òå˜ çà ìàñëîòî

N. Aëòå˜íàòî˜

O. Äàò…èê çà òåìïå˜àòó˜àòà íà îõëà¥äàùè àãåíò

P. ◊åíòèëàòî˜

Q. ˆåìúê çà âåíòèëàòî˜à

R. ¤çïóñêàòåëåí êîëåêòî˜

S. ›õëàäèòåë íà ìàñëîòî (àêî èìà òàêúâ)

Ðàáîòà

◊ìåñòèìîñò çà ìàñëî (íàï˜àâåòå ñï˜àâêà â ˜àçäåë Òåõíè÷åñêè äàííè)

Ïðåïîðúêè çà ìàñëîòî

Çà ïîëó…àâàíå íà íàé-äîá˜è òåõíè…åñêè ïîêàçàòåëè ï˜åïî˜ú…âàìå èçïîëçâàíåòî

íà ìàñëàòà íà Briggs & Stratton ñ ãà˜àíöè è ñå˜òèôèêàò çà êà…åñòâî. Ä˜óãè

âèñîêîêà…åñòâåíè ìàñëà ñ ìèåùè ï˜èñàäêè ñà ï˜èåìëèâè, àêî ñà êëàñèôèöè˜àíè

çà ˜àáîòíè ˜å¥èìè CF èëè CF-4. Äà íå ñå èçïîëçâàò ñïåöèàëíè äîáàâêè.

◊úíμíèòå òåìïå˜àòó˜è îï˜åäåëò ï˜àâèëíè âèñêîçèòåò íà ìàñëîòî çà

äâèãàòåë. ¤çïîëçâàéòå òàáëèöàòà, çà äà èçáå˜åòå íàé-äîá˜è âèñêîçèòåò çà

î…àêâàíè äèàïàçîí íà âúíμíèòå òåìïå˜àòó˜è.

SAE 30.

10W-30

Ñèíòåòè÷íî 5W-30

5W-30

°F °C

* æêî ï˜è òåìïå˜àòó˜è ïîä 40°F(4°C) ñå èçïîëçâà ìàñëî SAE 30, òîâà ùå

äîâåäå äî ò˜óäíî ñòà˜òè˜àíå íà äâèãàòåë.

** ﬁ˜è òåìïå˜àòó˜è íàä 80°F(27°C) èçïîëçâàíåòî íà ìàñëî 10 W-30 ìî¥å äà

ïîâèμè êîíñóìàöèòà íà ìàñëî. ﬁ˜îâå˜âàéòå ïî …åñòî íèâîòî ìó.

Êàê ñå ïðîâåðÿâà/íàëèâà ìàñëî - Ôèãóðà

2 4

Ïðåäè íàëèâàíå èëè ïðîâåðÿâàíå íà ìàñëîòî

• ˆàçïîëî¥åòå õî˜èçîíòàëíî äâèãàòåë.

• ﬁî…èñòåòå ìñòîòî îêîëî îòâî˜à çà íàëèâàíå íà ìàñëî îò âñè…êè îòëîìêè.

1. Ñâàëåòå íèâîïîêàçàòåë çà ìàñëîòî (A) è ãî èçáú˜μåòå ñ …èñò ïëàò (·èãó˜à

2).

2. ¤çöëî âìúêíåòå íèâîïîêàçàòåë çà ãî˜èâîòî.

3. Ñâàëåòå íèâîïîêàçàòåë è ï˜îâå˜åòå íèâîòî íà ìàñëîòî. ‚î ò˜áâà äà áúäå

äî ìà˜êè˜îâêàòà FULL (B) íà íèâîïîêàçàòåë.

4. æêî å íèñêî, ñâàëåòå íèâîïîêàçàòåë è íàëåéòå âíèìàòåëíî ìàñëî ï˜åç

îòâî˜à çà ïúëíåíå íà äâèãàòåë (C). Íå ãî ïðåïúëâàéòå.

Âàæíî: ÿîãàòî íàëèâàòå ìàñëî, ï˜àâèëíî âåíòèëè˜àíå ñå èçèñêâà, êàêòî

ñëåäâà:

• Ñâàëåòå íèâîïîêàçàòåë çà ìàñëîòî.

• ‡áåäåòå ñå, …å ïîääú˜¥àòå íó¥íîòî ˜àçñòîíèå (D) ìå¥äó ôóíèòà çà

íàëèâàíå íà ìàñëî (E) è ñòåíàòà íà îòâî˜à çà ïúëíåíå íà äâèãàòåë (C).

◊è¥òå ·èãó˜à 4.

5. Ñëåä íàëèâàíåòî íà ìàñëîòî, ïîñòàâåòå íèâîïîêàçàòåë. Ñòà˜òè˜àéòå è

îñòàâåòå äâèãàòåë äà ˜àáîòè ïåò ìèíóòè íà ï˜àçåí õîä. ¤çêë˚…åòå

äâèãàòåë. ¤ç…àêàéòå ò˜è ìèíóòè è ï˜îâå˜åòå íèâîòî íà ìàñëîòî. æêî ñå

íàëàãà, íàëåéòå îùå ìàñëî, çà äà äîñòèãíà íèâîòî ìó äî ìà˜êè˜îâêàòà FULL

(B) âú˜õó íèâîïîêàçàòåë (·èãó˜à 2).

6. ﬁîñòàâåòå íèâîïîêàçàòåë íà ìàñëîòî.

Íàëÿãàíå íà ìàñëîòî

æêî íèâîòî íà ìàñëîòî å ìíîãî íèñêî åäèí äàò…èê çà íàëãàíå (àêî èìà òàêúâ),

èëè ùå ñï˜å äâèãàòåë, èëè ùå çàäåéñòâà àëà˜ìåíîòî ìó óñò˜îéñòâî. æêî òîâà ñå

ñëó…è, ñï˜åòå äâèãàòåë è ï˜îâå˜åòå íèâîòî íà ìàñëîòî ñ íèâîïîêàçàòåë.

æêî íèâîòî íà ìàñëîòî å ïîä ìà˜êè˜îâêàòà ADD, äîáàâåòå ìàñëî, äîêàòî

äîñòèãíå ìà˜êè˜îâêàòà FULL. Ñòà˜òè˜àéòå äâèãàòåë è ï˜îâå˜åòå íàëãàíåòî,

ï˜åäè äà ï˜îäúë¥èòå äà ˜àáîòèòå.

æêî íèâîòî íà ìàñëîòî å ìå¥äó ìà˜êè˜îâêèòå ADD è FULL íå ñòàðòèðàéòå

äâèãàòåë. ›áú˜íåòå ñå êúì íêîé óïúëíîìîùåí ï˜åäñòàâèòåë íà Briggs &

Stratton çà äâèãàòåë 3 /LC, çà äà îòñò˜àíèòå ï˜îáëåìà ñ íàëãàíåòî íà ìàñëîòî.

Ïðåïîðúêè çà ãîðèâîòî

Ãîðèâîòî òðÿáâà äà îòãîâàðÿ íà ñëåäíèòå èçèñêâàíèÿ:

• Òîçè äâèãàòåë å ñúñ ñåðòèôèêàò çà ðàáîòà ñ äèçåëîâî ãîðèâî. Àêî íå ñå

èçïîëçâà ïîäõîäÿùîòî ãîðèâî ìîæå äà ñå ïîëó÷è ÷åðåí äèì, çàãóáà íà

ìîùíîñò è ïîâðåäà íà äâèãàòåëÿ, êîÿòî íÿìà äà áúäå ïîêðèòà îò

ãàðàíöèÿòà.

• ¤çïîëçâàéòå …èñòî, ï˜ñíî, äèçåëîâî ãî˜èâî ñ ìèíèìàëíî öåòàíîâî ÷èñëî

40. ﬁ˜ñíîòî ãî˜èâî ï˜åäîòâ˜àòâà îá˜àçóâàíåòî íà ñìîëà â ãî˜èâíàòà

ñèñòåìà. ÿóïóâàéòå ãî˜èâî â êîëè…åñòâî, êîåòî ìî¥å äà ñå èçïîëçâà â

˜àìêèòå íà 30 äíè. ◊è¥òå ˜àçäåë Ñêëàäèðàíå.

ÂÍÈÌÀÍÈÅ: ‹å èçïîëçâàéòå êå˜îñèí èëè áåíçèí âìåñòî äèçåëîâî ãî˜èâî.

‹åçïàçâàíåòî íà òîâà èçèñêâàíå âîäè äî ïîâ˜åäà íà äâèãàòåë è àíóëèðàíå íà

ãàðàíöèÿòà ìó.

Êàê ñå íàëèâà ìàñëî - Ôèãóðà

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ

Ãîðèâîòî è íåãîâèòå ïàðè ñà èçêëþ÷èòåëíî îãíåîïàñíè è

èçáóõëèâè.

Ïîæàð èëè âçðèâ ìîãàò äà ïðè÷èíÿò ñåðèîçíè îáãàðÿíèÿ èëè

ñìúðò.

Ïðè äîëèâàíå íà ãîðèâî

• ¤çêë˚…åòå äâèãàòåë è ãî îñòàâåòå äà ñå îõëàäè íàé-ìàëêî 2 ìèíóòè, ï˜åäè

äà ñâàëèòå êàïà…êàòà íà ˜åçå˜âîà˜à çà ãî˜èâî.

• ﬁúëíåòå ˜åçå˜âîà˜à çà ãî˜èâî íà îòê˜èòî èëè â äîá˜å âåíòèëè˜àíî

ïîìåùåíèå.

• ‹å ï˜åïúëâàéòå ˜åçå˜âîà˜à çà ãî˜èâî. ﬁúëíåòå ãî ï˜èáëèçèòåëíî 1,5 èí…à

(38 mm) ïî-íèñêî îò ãî˜íè ˜úá íà ãú˜ëîâèíàòà, çà äà ïîçâîëèòå ˜àçμè˜åíèå

íà ãî˜èâîòî.

• Ä˜ú¥òå ãî˜èâîòî äàëå… îò èñê˜è, îòê˜èòè ïëàìúöè, ñèãíàëíè ëàìïè,

òîïëèíà è ä˜óãè çàïàëèòåëíè èçòî…íèöè.

• ﬁ˜îâå˜âàéòå …åñòî ãî˜èâîï˜îâîäèòå, ˜åçå˜âîà˜à, êàïà…êàòà è

ñúåäèíåíèòà çà ïóêíàòèíè è òå…îâå. Çàìåíéòå ãè àêî å íåîáõîäèìî.

• æêî ãî˜èâîòî ñå ˜àçëåå, èç…àêàéòå äîêàòî òî ñå èçïà˜è, ï˜åäè äà ñòà˜òè˜àòå

äâèãàòåë.

1. ﬁî…èñòåòå ï˜îñò˜àíñòâîòî îêîëî êàïà…êàòà íà ˜åçå˜âîà˜à çà ãî˜èâî îò

ì˜úñîòè è íàñëîâàíè. Ñâàëåòå êàïà…êàòà (A,·èãó˜à5).

2. ‹àïúëíåòå ˜åçå˜âîà˜à çà ãî˜èâî (B) ñ ãî˜èâî. Çà äà ïîçâîëèòå ˜àçμè˜åíèå íà

ãî˜èâîòî, íå ïúëíåòå íàä äîëíàòà îñíîâà íà ãú˜ëîâèíàòà çà íàëèâàíå íà

ãî˜èâî (C).

3. ﬁîñòàâåòå îá˜àòíî êàïà…êàòà.

Ïðåïîðúêè çà îõëàæäàùàòà òå÷íîñò

◊ìåñòèìîñò çà îõëà¥äàùàòà òå…íîñò (âè¥òå ˆúêîâîäñòâîòî çà ˜àáîòà íà

ï˜îèçâîäèòåë íà îáî˜óäâàíåòî)

Âàæíî: ‚îâà å äâèãàòåë, îõëà¥äàí ñ îõëà¥äàùà òå…íîñò. 50/50% ñìåñ îò

íåñúäú˜¥àù ôîñôàòè àíòèô˜èç è âîäîï˜îâîäíà âîäà å íåîáõîäèìà çà

îõëà¥äàíå, îñèãó˜âàíå óñòîé…èâîñòòà íà êî˜îçè è ñìàçâàíåòî íà âîäíàòà

ïîìïà.

Êàê ñå ïðîâåðÿâà/íàëèâà îõëàæäàùàòà òå÷íîñò

Ìîãàò äà ñå ïîëó÷àò ñåðèîçíè èçãàðÿíèÿ îò îñâîáîæäàâàùàòà ñå

ïàðà èëè îò ãîðåùàòà îõëàæäàùà òå÷íîñò.

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ

• ‹Å Ñ◊æ⁄ßÉ‚Å êàïà…êèòå îò ˜àäèàòî˜à èëè ˜åçå˜âîà˜à, àêî äâèãàòåëòå

ãî˜åù èëè ˜àáîòè.

• Ñï˜åòå äâèãàòåë è ãî îñòàâåòå äà ñå îõëàäè, ï˜åäè ñà ñâàëíå êàïà…êèòå íà

˜àäèàòî˜à èëè ˜åçå˜âîà˜à è ï˜åäè ñìíàòà èëè íàëèâàíåòî íà îõëà¥äàùàòà

òå…íîñò.

1. ﬁ˜åäè ˜àáîòà, ï˜îâå˜åòå íèâîòî íà îõëà¥äàùàòà òå…íîñò. ‹èâîòî ù ò˜áâà

äà áúäå ìå¥äó ìà˜êè˜îâêèòå FULL è LOW/ADD, îòáåëçàíè íà ˜åçå˜âîà˜à çà

îõëà¥äàùà òå…íîñò. æêî íèâîòî ù å íèñêî, íàëåéòå â ˜åçå˜âîà˜à 50 /50%

ñìåñ îò àíòèô˜èç, êîéòî íå ñúäú˜¥à ôîñôàòè è âîäà îò âîäîñíàáäèòåëíàòà

ì˜å¥à.

2. Çà äà ñâàëèòå êàïà…êàòà íà ˜åçå˜âîà˜à, ñëåä êàòî äâèãàòåëò å îõëàäåí,

ïîñòàâåòå ïà˜…å äåáåë ïëàò âú˜õó íå. ◊íèìàòåëíî  îòâèéòå â ïîñîêà,

îá˜àòíà íà äâè¥åíèåòî íà …àñîâíèêîâàòà ñò˜åëêà.

3. æêî ˜åçå˜âîà˜úò å ï˜àçåí, äîëåéòå â íåãî è â ˜àäèàòî˜à îõëà¥äàùà ò å…íîñò.

‹àï˜àâåòå ñï˜àâêà â ˆúêîâîäñòâîòî çà ˜àáîòà ñ îáî˜óäâàíåòî îòíîñíî

˜àçïîëî¥åíèåòî, ˜àáîòàòà è ïîää˜ú¥êàòà íà ˜åçå˜âîà˜à è ˜àäèàòî˜à çà

îõëà¥äàùàòà òå…íîñò.

4. Çà äà ñâàëèòå êàïà…êàòà íà ˜àäèàòî˜à, ñëåä êàòî äâèãàòåëò å îõëàäåí,

ïîñòàâåòå ïà˜…å äåáåë ïëàò âú˜õó íå. ◊íèìàòåëíî  îòâèéòå â ïîñîêà,

îá˜àòíà íà äâè¥åíèåòî íà …àñîâíèêîâàòà ñò˜åëêà äî ïú˜âîòî ù ñïè˜àíå. æêî

ïîä íå èçëèçà ïà˜à ïîä íàëãàíå, çàñòàíåòå íàçàä, çà äà èçáåãíåòå

íà˜àíâàíå. Ñëåä êàòî íàëãàíåòî ñïàäíå, íàòèñíåòå êàïà…êàòà íà ˜àäèàòî˜à

íàäîëó è  îòâèéòå â ïîñîêà, îá˜àòíà íà äâè¥åíèåòî íà …àñîâíèêîâàòà

ñò˜åëêà.

Èçìåðâàòåëíè óðåäè è ñâåòëèííè èíäèêàòîðè

ﬁîêàçàíèòå èçìå˜âàòåëíè ó˜åäè è ñâåòëèííè èíäèêàòî˜è ñà ñòàíäà˜òíè è

ñúùåñòâóâàò â ˜àçëè…íè îïöèè, êîèòî ìîãàò äà áúäàò èçïîëçâàíè. ‹àï˜àâåòå

ñï˜àâêà â ˆúêîâîäñòâîòî çà ˜àáîòà ñ îáî˜óäâàíåòî îòíîñíî ˜àçïîëî¥åíèåòî è

˜àáîòàòà èì.

Òåðìîìåòúð çà îõëàæäàùàòà òå÷íîñò

ﬁîêàçâà òåìïå˜àòó˜àòà íà îõëà¥äàùàòà òå…íîñò, êîãàòî

êîíòàêòíèòêë˚… å íà ïîçèöè ON (◊êë.).

‹î˜ìàëåí îáõâàò - 80º √ 90º C (175º √ 195º F)

›ïàñåí îáõâàò - íàä 105º C (220º F)

×àñîâè áðîÿ÷

›ò…èòà ñóìà˜íè á˜îé ˜àáîòíè …àñîâå.

Èçìåðâàòåëåí óðåä çà íàëè÷íî ãîðèâî

ﬁîêàçâà îñòàâàùîòî â ˜åçå˜âîà˜à ãî˜èâî. Çà äà íàìàëèòå

êîíäåíçàöèòà íà âîäà, âèíàãè ïîääú˜¥àéòå ïúëåí ˜åçå˜âîà˜.

Ñâåòëèíåí èíäèêàòîð çà òåìïåðàòóðà

æêî ñâåòëèííèò èíäèêàòî˜ çà òåìïå˜àòó˜àòà ñâåòíå, çíà…è, …å

äâèãàòåëò å ï˜åã˜ë. Ñï˜åòå äâèãàòåë è ï˜îâå˜åòå íèâîòî íà

îõëà¥äàùàòà òå…íîñò (âè¥òå ˜àçäåë Êàê ñå ïðîâåðÿâà

îõëàæäàùàòà òå÷íîñò). ﬁ˜îâå˜âàéòå ˜àäèàòî˜à çà íàñëîâàíè, êîèòî ìîãàò

äà îã˜àíè…àò âúçäóμíè ïîòîê.

Ñâåòëèíåí èíäèêàòîð çà çàïàëâàíå

ÿîãàòî êîíòàêòíèòêë˚… å íà ïîçèöè ON (◊êë.), ñâåòëèííèò

èíäèêàòî˜ çà çàïàëâàíå ò˜áâà äà ñâåòè. Âîì äâèãàòåëò çà˜àáîòè,

èíäèêàòî˜úò ò˜áâà äà èçãàñíå. æêî èíäèêàòî˜úò íå ñâåòè ï˜è êîíòàêòåí êë˚…

íà ïîçèöè ON (◊êë.), ï˜îâå˜åòå çà èçãî˜ë ï˜åäïàçèòåë.

Ñâåòëèíåí èíäèêàòîð çà íàëÿãàíå íà ìàñëîòî â äâèãàòåëÿ

ÿîãàòî êîíòàêòíèòêë˚… å íà ïîçèöè ON (◊êë.), ñâåòëèííèò

èíäèêàòî˜ çà íàëãàíåòî íà ìàñëîòî ò˜áâà äà ñâåòè. Âîì

äâèãàòåëò çà˜àáîòè, ñâåòëèííèò èíäèêàòî˜ çà íàëãàíåòî íà ìàñëîòî ò˜áâà

äà çàãàñíå. æêî ñâåòëèííèò èíäèêàòî˜ çà íàëãàíåòî íà ìàñëîòî ñâåòè ï˜è

˜àáîòåù äâèãàòåë, íåçàáàâíî ãî ñï˜åòå. ﬁú˜âî ï˜îâå˜åòå íèâîòî íà ìàñëîòî

(íàï˜àâåòå ñï˜àâêà â ˜àçäåë Êàê ñå ïðîâåðÿâà/íàëèâà ìàñëî). Ñëåä òîâà

ï˜îâå˜åòå åëåêò˜è…åñêàòà ñèñòåìà.

Ñâåòëèíåí èíäèêàòîð çà çàðåæäàíå

ÿîãàòî êîíòàêòíèòêë˚… å íà ïîçèöè ON (◊êë.), ñâåòëèííèò

èíäèêàòî˜ çà çà˜å¥äàíå ò˜áâà äà ñâåòè. Âîì äâèãàòåëò

çà˜àáîòè, èíäèêàòî˜úò ò˜áâà äà èçãàñíå. æêî ñâåòëèííèò èíäèêàòî˜ çà

çà˜å¥äàíåòî ñâåòè ï˜è ˜àáîòåù äâèãàòåë, ï˜îâå˜åòå åëåêò˜è…åñêàòà ñèñòåìà.

Ñèãíàëíà ëàìïà çà íàãðåâíà ñâåù

ÿîãàòî êîíòàêòíèòêë˚… å íà ïîçèöè heat/glow èëè ïîçèöè on,

ñèãíàëíàòà ëàìïà ùå ïîêàçâà, …å íàã˜åâíèòå ñâåùè ï˜åäâà˜èòåëíî

çàã˜âàò ãî˜èâíàòà êàìå˜à.

Ñâåòëèíåí èíäèêàòîð çà ôèëòúðà çà ãîðèâî

Ñâåòëèííèò èíäèêàòî˜ çà ôèëòú˜à íà ãî˜èâîòî ñâåòâà, êîãàòî âúâ

ôèëòú˜à ñå å íàñúá˜àëà ìíîãî âîäà. ¤íäèêàòî˜úò ò˜áâà äà

çàãàñíå, êîãàòî èçëèμíàòà âîäà ñå èçòî…è îò ôèëòú˜à çà ãî˜èâîòî. æêî

ñâåòëèííèò èíäèêàòî˜ çà ôèëòú˜à íà ãî˜èâîòî ñâåòíå, êîãàòî äâèãàòåëò ˜àáîòè,

ñï˜åòå äâèãàòåë è èçòî…åòå âîäàòà îò ôèëòú˜à çà ãî˜èâîòî.

Êàê ñå ñòàðòèðà äâèãàòåëÿ - Ôèãóðà

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ

Ãîðèâîòî è íåãîâèòå ïàðè ñà èçêëþ÷èòåëíî îãíåîïàñíè è

èçáóõëèâè.

Ïîæàð èëè âçðèâ ìîãàò äà ïðè÷èíÿò ñåðèîçíè îáãàðÿíèÿ èëè

ñìúðò.

Ïðè ñòàðòèðàíå íà äâèãàòåëÿ

• ‡âå˜åòå ñå, …å μóìîçàãëó μèòåëò, êàïà…êàòà íà ˜åçå˜âîà˜à çà ãî˜èâî è

âúçäóμíèò ôèëòú˜ ñà íà ìåñòàòà èì è ñà äîá˜å çàê˜åïåíè.

• æêî äâèãàòåëò ñå çàäàâè, ïîñòàâåòå ñìóêà…à (àêî èìà òàêúâ) íà ïîçèöè

open/run, ï˜èäâè¥åòå ˜ú…íàòà ãàç (àêî èìà òàêàâà) íà ïîçèöè∆fast∆ è

˜àçâú˜òàéòå, äîêàòî äâèãàòåëò ñòà˜òè˜à.

• Çà äà ï˜îäúë¥èòå ¥èâîòà íà ñòà˜òå˜à, èçïîëçâàéòå ê˜àòêè ñòà˜òîâè öèêëè,

íå ïî-äúëãè îò 15 ñåê/ìèí. ﬁ˜îäúë¥èòåëíîòî ˜àçâú˜òàíå ìî¥å äà ïîâ˜åäè

ñòà˜òå˜à.

Äâèãàòåëèòå èçïóñêàò âúãëåðîäåí îêèñ, êîéòî å îòðîâåí ãàç, áåç

ìèðèñ è öâÿò.

Âäèøâàíåòî íà âúãëåðîäåí îêèñ ìîæå äà ïðè÷èíè ãàäåíå,

ïðèïàäúê èëè ñìúðò.

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ

• Ñòà˜òè˜àéòå è ˜àáîòåòå ñ äâèãàòåë íàâúí.

• ‹å ñòà˜òè˜àéòå è íå ˜àáîòåòå ñ äâèãàòåë â çàòâî˜åíî ïîìåùåíèå, äî˜è è ï˜è

îòâî˜åíè â˜àòè èëè ï˜îçî˜öè.

ÂÍÈÌÀÍÈÅ: ‹àñòîùèò äâèãàòåë ñå äîñòàâ îò Briggs & Stratton áåç ìàñëî.

ﬁ˜åäè äà ñòà˜òè˜àòå äâèãàòåë ñå óâå˜åòå, …å ñòå íàëåëè ìàñëî â íåãî ñïî˜åä

èíñò˜óêöèèòå â òîâà ˜úêîâîäñòâî. æêî ãî ñòà˜òè˜àòå áåç ìàñëî, ò îé ùà ñå

ïîâ˜åäè áåç äà áúäå âúçìî¥íî äà ñå ˜åìîíòè˜à è ãà˜àíöèòà íìà äà ïîê˜èâà

ùåòàòà.

ÂÍÈÌÀÍÈÅ: ﬁ˜åäè äà ñòà˜òè˜àòå äâèãàòåë çà ïú˜âè ïúò, çà˜åäåòå

àêóìóëàòî˜à, êàêòî ñå ï˜åïî˜ú…âà îò ï˜îèçâîäèòåë íà îáî˜óäâàíåòî.

‹åñçïàçâàíåòî íà òîâà èçèñêâàíå ìî¥å äà ï˜è…èíè ïîâ˜åäà íà äâèãàòåë.

Çàáåëåæêà: ‹êîè äâèãàòåëè è îáî˜óäâàíå ñà ñíàáäåíè ñ óñò˜îéñòâà çà

äèñòàíöèîííî óï˜àâëåíèå. ‹àï˜àâåòå ñï˜àâêà â ˆúêîâîäñòâîòî çà ˜àáîòà ñ

îáî˜óäâàíåòî ç à ˜àçïîëî¥åíèåòî è ˜àáîòàòà ñ óñò˜îéñòâàòà çà äèñòàíöèîííî

óï˜àâëåíèå.

1. ﬁ˜îâå˜åòå íèâîòî íà ìàñëîòî. ‹àï˜àâåòå ñï˜àâêà â ˜àçäåëà Êàê ñå

ïðîâåðÿâà/íàëèâà ìàñëî.

2. ‡âå˜åòå ñå, …å çàäâè¥âàùèòå óï˜àâëåíè íà îáî˜óäâàíåòî, àêî èìà òàêèâà,

ñà èçêë˚…åíè.

3. Çàâú˜òåòå ê˜àí…åòî çà ïîäàâàíå íà ãî˜èâî (A), àêî èìà òàêîâà, íà ïîçèöè

∆on∆ (·èãó˜à 6).

4. ﬁ˜åìåñòåòå ëîñòà íà ˜ú…íàòà ãàç (B) íà ïîçèöè slow

Çàáåëåæêà: Çà ñòà˜òè˜àíå â ñòóäåíî â˜åìå (ïîä -10º Cèëè14º F), ïîñòàâåòå

ëîñòà çà ˜ú…íàòà ãàç íà ïîçèöè fast

5. Çàâú˜òåòå êë˚…à çà åëåêò˜è…åñêè ñòà˜òå˜ (D) íà ïîçèöè ON èëè HEAT

(·èãó˜à 6). Ñèãíàëíàòà ëàìïà çà ñâåùèòå ùå ïîêà¥å, …å ïîäã˜âàùèòå ñâåùè

ï˜åäâà˜èòåëíî çàã˜âàò ãî˜èâíàòà êàìå˜à.

6. Âîì ñèãíàëíàòà ëàìïà çà ñâåùèòå çàãàñíå, çàâú˜òåòå êë˚…à íà

åëåêò˜è…åñêè ñòà˜òå˜ íà ïîçèöè START.

ÂÍÈÌÀÍÈÅ: Çà äà ï˜îäúë¥èòå ¥èâîòà íà ñòà˜òå˜à, èçïîëçâàéòå ê˜àòêè

ñòà˜òîâè öèêëè, íå ïî-äúëãè îò 15 ñåê/ìèí. ﬁ˜îäúë¥èòåëíîòî ˜àçâú˜òàíå

ìî¥å äà ïîâ˜åäè ñòà˜òå˜à.

7. ÿîãàòî äâèãàòåëò ñòà˜òè˜à, îñâîáîäåòå êë˚…à. Ñèãíàëíàòà ëàìïà ùå ñâåòíå

çà îêîëî 20 ñåêóíäè è ñëåä òîâà ùå çàãàñíå.

ÂÍÈÌÀÍÈÅ: Íå ïîäàâàéòå ãàç è íå ïîâèμàâàéòå îáî˜îòèòå íà ñòóäåí

äâèãàòåë. ‹åñïàçâàíåòî íà òîâà èçèñêâàíå ìî¥å äà ï˜è…èíè ïîâ˜åäà íà

äâèãàòåë.

8. ›ñòàâåòå äâèãàòåëòäà˜àáîòèèäàçàã˜ååâï˜îäúë¥åíèåíàíêîëêî

ìèíóòè, ï˜åäè äà ñå ˜àáîòè ñ îáî˜óäâàíåòî.

Êàê äà ñïðåòå äâèãàòåëÿ - Ôèãóðà

1. ﬁ˜åìåñòåòå ëîñòà íà ˜ú…íàòà ãàç (B) íà ïîçèöè slow .

ÂÍÈÌÀÍÈÅ: ﬁ˜åäè ñ ïè˜àíå íà äâèãàòåë ñ òó˜áîêîìï˜åñî˜, ãî îñòàâåòå íà

áàâíè îáî˜îòè çà îêîëî åäíà ìèíóòà, çà äà ñå îõëàäè òó˜áîêîìï˜åñî˜úò. ﬁ˜è

ï˜îïóñê íà òîâà äåéñòâèå òó˜áîêîìï˜åñî˜úò ìî¥å äà ñå ïîâ˜åäè.

2. Çàâú˜òåòå êë˚…à (D) íà ïîçèöè off (èçêë.) (·èãó˜à 6). Ñâàëåòå êë˚…àèãî

ä˜ú¥òå íà áåçîïàñíî ìñòî, äàëå… îò îáñåãà íà äåöà.

3. Ñëåä ñïè˜àíå íà äâèãàòåë, çàâú˜òåòå ê˜àí…åòî çà ïîäàâàíå íà ãî˜èâî (A),

àêî èìà òàêîâà, íà çàòâî˜åíà ïîçèöè.

BRIGGSandSTRATTON.COM

Òåõíè÷åñêî îáñëóæâàíå

Èçïîëçâàéòå ñàìî îðèãèíàëíè ðåçåðâíè ÷àñòè. Äðóãè ÷àñòè ìîæå äà íå

ñðàáîòÿò äîáðå, ìîæå äà ïîâðåäÿò äâèãàòåëÿ è äà äîâåäàò äî íàðàíÿâàíå.

›ñâåí òîâà, èçïîëçâàíåòî íà ä˜óãè …àñòè ìî¥å äà àíóëè˜à ãà˜àíöèòà âè.

‹èå âè ï˜åïî˜ú…âàìå äà ïîñåòèòå íêîé îò ‡ïúëíîìîùåíèòå ï˜åäñòàâèòåëè íà

Briggs & Stratton çà âñè…êè îïå˜àöèè ïî òåõíè…åñêîòî è ñå˜âèçíîòî îáñëó¥âàíå íà

äâèãàòåë 3/LC è ˜åçå˜âíèòå …àñòè.

ÂÍÈÌÀÍÈÅ: ◊ñè…êè êîìïîíåíòè, èçïîëçâàíè ï˜è ï˜îèçâîäñòâîòî íà òîçè

äâèãàòåë, ò˜áâà äà áúäàò íà ìñòîòî ñè çà ï˜àâèëíàòà ìó ˜àáîòà.

ÂÍÈÌÀÍÈÅ: ﬁ˜îèçâîäèòåëò íà îáî˜óäâàíåòî, íà êîåòî òîçè äâèãàòåë ùå áúäå

ìîíòè˜àí, îï˜åäåë ìàêñèìàëíèòå îáî˜îòè, ï˜è êîèòî ùå ˜àáîòè äâèãàòåëò. Íå

íàäâèøàâàéòå òåçè îáî˜îòè.

Êîíòðîë íà åìèñèèòå

Ïîääðúæêàòà, ñìÿíàòà èëè ðåìîíòúò íà óñòðîéñòâàòà çà êîíòðîë íà

âðåäíèòå åìèñèè ìîãàò äà áúäàò èçâúðøâàíè îò âñåêè ðåìîíòåí öåõ èëè

òåõíèê, ðåìîíòèðàùè äâèãàòåëè, êîèòî íå ñå èçïîëçâàò çà òðàíñïîðòíè öåëè.

◊ñå ïàê, çà äà ïîëó…èòå ∆áåçïëàòíî∆ îáñëó¥âàíå íà óñò˜îéñòâàòà çà êîíò˜îë íà

â˜åäíèòå åìèñèè, ˜àáîòàòà ò˜áâà äà áúäå èçâú˜μåíà îò óïúëíîìîùåí çàâîäñêè

ï˜åäñòàâèòåë. ‹àï˜àâåòå ñï˜àâêà â øà˜àíöèòà îòíîñíî â˜åäíèòå åìèñèè.

Íåâîëíî ñòàðòèðàíå ìîæå äà äîâåäå äî çàõâàùàíå, òðàâìàòè÷íà

àìïóòàöèÿ èëè äî ðàíÿâàíå.

Îïàñíîñò îò ïîæàð

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ

Ïðåäè èçâúðøâàíå íà ðåãóëèðîâêè è ïîïðàâêè:

• ›òêà…åòå ìèíóñ-êëåìàòà íà àêóìóëàòî˜à (ñàìî ï˜è äâèãàòåëè ñ åëåêò˜è…åñêè

ñòà˜òå˜).

• ¤çïîëçâàéòå ñàìî ïîäõîäùè èíñò˜óìåíòè.

• ‹å çàñòîïî˜âàéòå ñ ˜åãóëè˜àùàòà ï˜ó¥èíà, ëîñòîâèòå ñèñòåìè èëè ñ ä˜óãè

…àñòè, çà äà ïîâèμèòå îáî˜îòèòå íà äâèãàòåë.

• ˆåçå˜âíèòå …àñòè ò˜áâà äà áúäàò ñúñ ñúùîòî êà…åñòâî è äà ñå ìîíòè˜àò â

ñúùàòà ïîçèöè, êàêòî î˜èãèíàëíèòå …àñòè.

• ‹å óä˜éòå ìàõîâèêà ñ …óê èëè òâú˜ä ï˜åäìåò, çàùîòî òîé ìî¥å äà ñå ñò˜îμè

ïî â˜åìå íà ˜àáîòà.

Ãðàôèê çà òåõíè÷åñêî îáñëóæâàíå

Íà âñåêè 8 ÷àñà èëè åæåäíåâíî

• Äà ñå ï˜îâå˜âà íèâîòî íà ìàñëîòî â äâèãàòåë

• Äà ñå ï˜îâå˜âà íèâîòî íà îõëà¥äàùàòà òå…íîñò

Ñëåä ïúðâèòå 50 ÷àñà ðàáîòà (Íà÷àëíà ðàçðàáîòêà)

• Äà ñå ñìåí ìàñëîòî íà äâèãàòåë *

Íà âñåêè 100 ÷àñà

• Äà ñå ï˜îâå˜âà îïúâàíåòî íà âåíòèëàòî˜íè ˜åìúê

• Äà ñå ïî…èñòâà ˜àäèàòî˜à

• Äà ñå ïî…èñòâà âúçäóμíè ôèëòú˜

• Äà ñå ï˜îâå˜âà μóìîçàãëóμèòåë è äà ñå ïî…èñòâà èñê˜îãàñèòåë (àêî

èìà òàêèâà)

Íà âñåêè 150 ÷àñà

• Äà ñå ñìåí ìàñëîòî íà äâèãàòåë *

• Äà ñå ñìåí ìàñëåíè ôèëòú˜

Íà âñåêè 600 ÷àñà èëè åæåãîäíî

• Äà ñå ñìåí âúçäóμíè ôèëòú˜.

• Äà ñå ï˜îâå˜âà ìå¥äèíàòà íà êëàïàíèòå H

• Äà ñå ñìåíâà ôèëòú˜à çà ãî˜èâîòî

Íà âñåêè 1500 ÷àñà

• Äà ñå ï˜îâå˜âàò íàãíåòàòåëíèòå ä˚çè z

Åæåãîäíî

• Äà ñå ñìåí ìàñëîòî íà äâèãàòåë *

• Äà ñå ñìåí ìàñëåíè ôèëòú˜

• Äà ñå ñìåí îõëà¥äàùàòà òå…íîñò

• Äà ñå ï˜îâå˜âà îïúâàíåòî íà âåíòèëàòî˜íè ˜åìúê

• Äà ñå ïî…èñòâà ˜àäèàòî˜à

• Äà ñå ï˜îâå˜âà μóìîçàãëóμèòåë è äà ñå ïî…èñòâà èñê˜îãàñèòåë (àêî

èìà òàêèâà)

• Äà ñå ñìåí âúçäóμíè ôèëòú˜.

• Äà ñå ñìåíâà ôèëòú˜à çà ãî˜èâîòî

• Äà ñå ï˜îâå˜âà ìå¥äèíàòà íà êëàïàíèòå H

* Äà ñå ï˜îâå¥äà ïî-…åñòî îáñëó¥âàíå, êîãàòî ˜àáîòíèò ˜å¥èì å òå¥úê èëè ñå

˜àáîòè ï˜è âèñîêè òåìïå˜àòó˜è.

æêî íå ñå èçïîëçâà î˜èãèíàëíà …àñò íà Briggs & Stratton, ñëåäâàéòå ã˜àôèêà çà

òåõíè…åñêî ïîääú˜¥àíå íà ï˜îèçâîäèòåë è.

z ›áñëó¥âàíåòî ò˜áâà äà áúäå èçâú˜μåíî îò óïúëíîìîùåí ï˜åäñòàâèòåë íà

’DENSO∆.

H ‹å ñå íàëàãà, îñâåí àêî íå áúäàò çàáåëçàíè ï˜îáëåìè ñ òåõíè…åñêèòå

ïîêàçàòåëè íà äâèãàòåë.

Äà ñå ïðîâåðÿâà âíèìàòåëíî øóìîçàãëóøèòåëÿ è

èñêðîãàñèòåëÿ

Ðàáîòåùèòå äâèãàòåëè îòäåëÿò òîïëèíà. ×àñòèòå íà äâèãàòåëèòå,

îñîáåíî øóìîçàãëóøèòåëÿ, ñòàâàò èçêëþ÷èòåëíî ãîðåùè.

Ïðè äîïèð ìîæå äà ïîëó÷èòå ñåðèîçíî èçãàðÿíå.

Ãîðèìèòå îòïàäúöè, êàòî ëèñòà, òðåâè, õðàñòàëàê è äðóãè, ìîãàò äà

ñå çàïàëÿò.

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ

• ›ñòàâåòå μóìîçàãëóμèòåë, öèëèíäú˜à íà äâèãàòåë è ˜åá˜àòà äà ñå

îõëàäò, ï˜åäè äà ãè äîêîñâàòå.

• ›òñò˜àíåòå íàò˜óïàíèòå îòëîìêè îêîëî μóìîçàãëóμèòåë è öèëèíäú˜à.

• ﬂîíòè˜àéòå è ïîääú˜¥àéòå â ˜àáîòíî ñúñòîíèå èñê˜îãàñèòåë, ï˜åäè äà

èçïîëçâàòå äâèãàòåë íà çàëåñåíè ìåñòà, çàò˜åâåíè ïëîùè, ïëîùè ñ õ˜àñòè è

íåîá˜àáîòåíè ìåñòà. Âàòúò ÿàëèôî˜íè èçèñêâà òîâà (â ˆàçäåë 4442 íà

ÿàëèôî˜íèéñêè ï˜àâèëíèê çà îáùåñòâåíè ˜åñó˜ñè). ◊úçìî¥íîåä˜óãèùàòè

äà èìàò ïîäîáíè çàêîíè. ·åäå˜àëíèòå çàêîíè ñå ï˜èëàãàò íà ôåäå˜àëíà

òå˜èòî˜è.

ﬁ˜îâå˜åòå μóìîçàãëóμèòåë çà ïóêíàòèíè, êî˜îçè èëè ä˜óã âèä ïîâ˜åäà.

Ñâàëåòå èñê˜îãàñèòåë, àêî èìà òàêúâ, è ãî ï˜îâå˜åòå çà ïîâ˜åäà èëè çàïóμâàíå

ñúñ ñà¥äè. æêî ñå íàëàãà èçïîëçâàíåòî íà ˜åçå˜âíè …àñòè ñå óáåäåòå, …å ùå

áúäàò ìîíòè˜àíè åäèíñòâåíî î˜èãèíàëíè ˜åçå˜âíè ìàμèííè …àñòè.

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ: ˆåçå˜âíèòå …àñòè ò˜áâà äà áúäàò ñúùèòå

êàòî ñìåíâàíèòå è äà ñå ìîíòè˜àò â ñúùàòà ïîçèöè, êàêòî î˜èãèíàëíèòå

òàêèâà, ïî˜àäè îïàñíîñò îò âúçíèêâàíå íà ïî¥à˜.

Êàê ñå ïðîâåðÿâà îõëàæäàùàòà òå÷íîñò

Âàæíî: ‚îâà å äâèãàòåë ñ îõëà¥äàùà òå…íîñò. Çà îõëà¥äàíå, îñèãó˜âàíå

óñòîé…èâîñòòà íà êî˜îçè è ñìàçâàíå íà âîäíàòà ïîìïà å íåîáõîäèìà ñìåñ

50/50% îò àíòèô˜èç, êîéòî íå ñúäú˜¥à ôîñôàòè è âîäà îò âîäîñíàáäèòåëíàòà

ì˜å¥à.

Ìîãàò äà ñå ïîëó÷àò ñåðèîçíè èçãàðÿíèÿ îò îñâîáîæäàâàùàòà ñå

ïàðà èëè îò ãîðåùàòà îõëàæäàùà òå÷íîñò.

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ

• ‹Å Ñ◊æ⁄ßÉ‚Å êàïà…êèòå îò ˜àäèàòî˜à èëè ˜åçå˜âîà˜à, àêî äâèãàòåëòå

ãî˜åù èëè ˜àáîòè.

• Ñï˜åòå äâèãàòåë è ãî îñòàâåòå äà ñå îõëàäè, ï˜åäè ñà ñâàëíå êàïà…êèòå íà

˜àäèàòî˜à èëè ˜åçå˜âîà˜à è ï˜åäè ñìíàòà èëè íàëèâàíåòî íà îõëà¥äàùàòà

òå…íîñò.

1. ﬁ˜îâå˜åòå íèâîòî íà îõëà¥äàùàòà òå…íîñò. ‹èâîòî ù ò˜áâà äà áúäå ìå¥äó

ìà˜êè˜îâêèòå FULL è LOW, èëè ADD, îòáåëçàíè íà ˜åçå˜âîà˜à çà

îõëà¥äàùà òå…íîñò. æêî íèâîòî ù å íèñêî, íàëåéòå â ˜åçå˜âîà˜à ñìåñ

50/50% îò àíòèô˜èç, êîéòî íå ñúäú˜¥à ôîñôàòè è âîäà îò

âîäîñíàáäèòåëíàòà ì˜å¥à.

2. Çà äà ñâàëèòå êàïà…êàòà íà ˜åçå˜âîà˜à, ñëåä êàòî äâèãàòåëò å îõëàäåí,

ïîñòàâåòå ïà˜…å äåáåë ïëàò âú˜õó íå. ◊íèìàòåëíî  îòâèéòå â ïîñîêà,

îá˜àòíà íà äâè¥åíèåòî íà …àñîâíèêîâàòà ñò˜åëêà.

3. æêî ˜åçå˜âîà˜úò å ï˜àçåí, äîëåéòå îõëà¥äàùà òå…íîñò â íåãîèâ˜àäèàòî˜à.

›òíîñíî ˜àçïîëî¥åíèåòî, ˜àáîòàòà è ïîää˜ú¥êàòà íà ˜åçå˜âîà˜à è

˜àäèàòî˜à çà îõëà¥äàùàòà òå…íîñò, íàï˜àâåòå ñï˜àâêà â ˆúêîâîäñòâîòî çà

˜àáîòà ñ îáî˜óäâàíåòî.

4. Çà äà ñâàëèòå êàïà…êàòà íà ˜àäèàòî˜à, ñëåä êàòî äâèãàòåëò å îõëàäåí,

ïîñòàâåòå ïà˜…å äåáåë ïëàò âú˜õó íå. ◊íèìàòåëíî  îòâèéòå â ïîñîêà,

îá˜àòíà íà äâè¥åíèåòî íà …àñîâíèêîâàòà ñò˜åëêà äî ïú˜âîòî ù ñïè˜àíå. æêî

ïîä íå èçëèçà ïà˜à ïîä íàëãàíå, çàñòàíåòå íàçàä, çà äà èçáåãíåòå

íà˜àíâàíå. Ñëåä êàòî íàëãàíåòî ñïàäíå, íàòèñíåòå êàïà…êàòà íà ˜àäèàòî˜à

íàäîëó è  îòâèéòå â ïîñîêà, îá˜àòíà íà äâè¥åíèåòî íà …àñîâíèêîâàòà

ñò˜åëêà.

Êàê ñå ñìåíÿâà ìàñëîòî - Ôèãóðà

2 3

ÂÍÈÌÀÍÈÅ: ›ò˜àáîòèëîòî ìàñëî å îïàñåí îòïàäú…åí ï˜îäóêò è ò˜áâàäàñå

ñêëàäè˜à ïî ïîäõîäù íà…èí. ‹å ãî èçõâú˜ëéòå ñ äîìàêèíñêèòå îòïàäúöè.

ﬁ˜îâå˜åòå ñúâìåñòíî ñ îáùèíñêèòå âëàñòè, çà îáñëó¥âàù öåíòú˜ èëè ç à

ï˜åäñòàâèòåë íà èíñòàëàöèè çà áåçîïàñíî äåïîíè˜àíå/˜åöèêëè˜àíå íà

îò˜àáîòèëîòî ìàñëî.

Èçòî÷âàíå íà ìàñëîòî

1. Ñâàëåòå ï˜îáêàòà îò îòâî˜à çà èçòî…âàíå íà ìàñëîòî (G, ·èãó˜à 3). ¤çòî…åòå

ãî â ïîäõîäù êîíòåéíå˜.

2. Ñëåä êàòî ìàñëîòî å èçòî…åíî, ïîñòàâåòå è çàòåãíåòå ï˜îáêàòà.

Ñìÿíà íà ìàñëåíèÿ ôèëòúð

›òíîñíî èíòå˜âàëèòå çà ñìíàòà ìó íàï˜àâåòå ñï˜àâêà â êà˜òàòà Òåõíè÷åñêî

îáñëóæâàíå.

1. ¤çòî…âàíå íà ìàñëîòî îò äâèãàòåë. ‹àï˜àâåòå ñï˜àâêà â ˜àçäåë Èçòî÷âàíå

íà ìàñëîòî.

2. Ñâàëåòå ìàñëåíè ôèëòú˜ (H, ·èãó˜à 3) è ãî äåïîíè˜àéòå ïî ïîäõîäùè

íà…èí.

3. ﬁ˜åäè äà ì îíòè˜àòå íîâè ìàñëåí ôèëòú˜, ëåêî ñìà¥åòå ôèëòú˜íàòà

ãà˜íèòó˜à ñ íîâî, …èñòî ìàñëî.

4. ﬂîíòè˜àéòå ìàñëåíè ôèëòú˜ íà ˜úêà, äîêàòî ãà˜íèòó˜àòà îï˜å âúâ

ôèëòú˜íè àäàïòå˜, ñëåä êîåòî ãî çàòåãíåòå ñ îùå 1/2 äî 3/4 îáî˜îòà.

5. ‹àëèâàíå íà ìàñëî. ‹àï˜àâåòå ñï˜àâêà â ˜àçäåë Íàëèâàíå íà ìàñëî.

Íàëèâàíå íà ìàñëî

• ˆàçïîëî¥åòå õî˜èçîíòàëíî äâèãàòåë.

• ﬁî…èñòåòå ìñòîòî îêîëî îòâî˜à çà íàëèâàíå íà ìàñëî îò âñè…êè îòëîìêè.

• ‹àï˜àâåòå ñï˜àâêà â ˜àçäåë Òåõíè÷åñêè äàííè îòíîñíî âìåñòèìîñòòà çà

ìàñëîòî.

1. Ñâàëåòå íèâîïîêàçàòåë (A,·èãó˜à2).

2. ‹àëåéòå âíèìàòåëíî ìàñëîòî â äâèãàòåë ï˜åç îòâî˜à çà ïúëíåíå (C). Íå

ïðåïúëâàéòå.

Âàæíî: ÿîãàòî íàëèâàòå ìàñëî, ï˜àâèëíî âåíòèëè˜àíå ñå èçèñêâà, êàêòî

ñëåäâà:

• Ñâàëåòå íèâîïîêàçàòåë çà ìàñëîòî.

• ‡áåäåòå ñå, …å ïîääú˜¥àòå íó¥íîòî ˜àçñòîíèå (D) ìå¥äó ôóíèòà çà

íàëèâàíå íà ìàñëî (E) è ñòåíàòà íà îòâî˜à çà ïúëíåíå íà äâèãàòåë (C).

◊è¥òå ·èãó˜à 4.

3. Ñëåä íàëèâàíåòî íà ìàñëîòî, ïîñòàâåòå íèâîïîêàçàòåë. Ñòà˜òè˜àéòå è

îñòàâåòå äâèãàòåë äà ˜àáîòè ïåò ìèíóòè íà ï˜àçåí õîä. ﬁ˜îâå˜åòå çà

òå…îâå. ¤çêë˚…åòå äâèãàòåë. ¤ç…àêàéòå ò˜è ìèíóòè è ï˜îâå˜åòå íèâîòî íà

ìàñëîòî. æêî ñå íàëàãà, íàëåéòå îùå ìàñëî, çà äà äîñòèãíå íèâîòî ìó äî

ìà˜êè˜îâêàòà FULL (B) âú˜õó íèâîïîêàçàòåë (·èãó˜à 2).

4. ﬁîñòàâåòå íèâîïîêàçàòåë íà ìàñëîòî.

Êàê äà ñå îáñëóæâà âúçäóøíèÿ ôèëòúð - Ôèãóðà

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ

Ãîðèâîòî è íåãîâèòå ïàðè ñà èçêëþ÷èòåëíî îãíåîïàñíè è

èçáóõëèâè.

Ïîæàð èëè âçðèâ ìîãàò äà ïðè÷èíÿò ñåðèîçíè îáãàðÿíèÿ èëè

ñìúðò.

• ‹èêîãà íå ñòà˜òè˜àéòå è íå ˜àáîòåòå ñ äâèãàòåë ï˜è îòñò˜àíåí êîìïëåêò íà

âúçäóμíè ôèëòú˜.

ÂÍÈÌÀÍÈÅ: ‹å èçïîëçâàéòå ñãúñòåí âúçäóõ èëè ˜àçòâî˜èòåëè, çà äà ïî…èñòâàòå

ôèëòú˜à. Ñãúñòåíèò âúçäóõ ìî¥å äà ïîâ˜åäè ôèëòú˜à, à ˜àçòâî˜èòåëèòå ãî

˜àçòâà˜ò.

›òíîñíî èçèñêâàíè òà çà ñå˜âèçíî îáñëó¥âàíå, íàï˜àâåòå ñï˜àâêà â Êàðòàòà çà

òåõíè÷åñêîòî îáñëóæâàíå.

1. ›òâî˜åòå ôèêñàòî˜èòå (A) è ñâàëåòå êàïàêà (B). ◊è¥òå ·èãó˜à 7.

2. Ñâàëåòå âúçäóμíè ôèëòú˜ (C).

3. Çà äà îòñò˜àíèòå íàñëîâàíèòà, âíèìàòåëíî ïî…óêâàéòå âúçäóμíè ôèëòú˜

âú˜õó òâú˜äà ïîâú˜õíîñò. æêî å ï˜åêàëåíî çàìú˜ñåí, ñìåíåòå ãî ñ íîâ

ôèëòú˜.

4. ﬂîíòè˜àéòå âúçäóμíè ôèëòú˜.

5. ﬁîñòàâåòå êàïàêà è çàòâî˜åòå ôèêñàòî˜èòå.

Êàê ñå ñìåíÿ ôèëòúðà çà ãîðèâî - Ôèãóðà

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ

Ãîðèâîòî è íåãîâèòå ïàðè ñà èçêëþ÷èòåëíî îãíåîïàñíè è

èçáóõëèâè.

Ïîæàð èëè âçðèâ ìîãàò äà ïðè÷èíÿò ñåðèîçíè îáãàðÿíèÿ èëè

ñìúðò.

• ›òêà…åòå ìèíóñ-êëåìàòà íà àêóìóëàòî˜à (ñàìî ï˜è äâèãàòåëè ñ åëåêò˜è…åñêè

ñòà˜òå˜).

• Ä˜ú¥òå ãî˜èâîòî äàëå… îò èñê˜è, îòê˜èòè ïëàìúöè, ñèãíàëíè ëàìïè,

òîïëèíà è ä˜óãè çàïàëèòåëíè èçòî…íèöè.

• ﬁ˜îâå˜âàéòå …åñòî ãî˜èâîï˜îâîäèòå, ˜åçå˜âîà˜à, êàïà…êàòà è

ñúåäèíåíèòà çà ïóêíàòèíè è òå…îâå. Çàìåíéòå ãè àêî å íåîáõîäèìî.

• ﬁ˜åäè ñìíà íà ôèëòú˜à çà ãî˜èâî, èçòî…åòå ˜åçå˜âîà˜à çà ãî˜èâî èëè

çàòâî˜åòå ê˜àí…åòî çà ïîäàâàíå íà ãî˜èâî.

• ˆåçå˜âíèòå …àñòè ò˜áâà äà áúäàò ñúñ ñúùîòî êà…åñòâî è äà ñå ìîíòè˜àò â

ñúùàòà ïîçèöè, êàêòî î˜èãèíàëíèòå …àñòè.

• æêî ãî˜èâîòî ñå ˜àçëåå, èç…àêàéòå äîêàòî òî ñå èçïà˜è, ï˜åäè äà ñòà˜òè˜àòå

äâèãàòåë.

æêî ñâåòëèííèò ï˜åäóï˜å¥äàâàù èíäèêàòî˜ çà ôèëòú˜à íà ãî˜èâîòî ñ âåòíå,

äîêàòî äâèãàòåëò ˜àáîòè, ñï˜åòå ãî è èçòî…åòå âîäàòà îò ôèëòú˜à çà ãî˜èâîòî,

êàêòî ñëåäâà:

Ñìåíåòå ôèëòúðà çà ãîðèâîòî

1. ˆàçåäèíåòå ï˜îâîäíèêà íà äàò…èêà D.

2. Ñâàëåòå ï˜îáêàòà çà èçòî…âàíå (B) è èçõâú˜ëåòå O-ï˜úñòåíà (E).

3. Ñâàëåòå ôèëòú˜à çà ãî˜èâîòî (A) ñ ãàå…åí êë˚… çà ôèëòú˜.

4. ﬂîíòè˜àéòå íîâ ôèëòú˜ çà ãî˜èâîòî íà ˜úêà, äîêàòî ãà˜íèòó˜àòà ( F) îï˜å â

êà˜òå˜à. Ñëåä òîâà çàòåãíåòå äîïúëíèòåëíî ñ îùå 1/3 îáî˜îò.

5. ﬂîíòè˜àéòå ï˜îáêàòà çà èçòî…âàíå ñ íîâ O-ï˜úñòåí.

6. Ñâú˜¥åòå êàáåëà íà äàò…èêà.

7. Çàäåéñòâàéòå ïîäêà…âàùàòà ïîìïà (C), äîêàòî óñåòèòå ñúï˜îòèâëåíèå.

8. Ñòà˜òè˜àéòå äâèãàòåë è ï˜îâå˜åòå çà òå…îâå.

Èçòî÷åòå âîäàòà îò ôèëòúðà çà ãîðèâîòî

1. Ñï˜åòå äâèãàòåë.

2. ﬁîñòàâåòå âàíàòà çà èçòî…âàíå ïîä ôèëòú˜à çà ãî˜èâî (A) è ˜àçõëàáåòå

ï˜îáêàòà çà èçòî…âàíå (B) ñ îêîëî åäèí îáî˜îò.

3. ◊îäàòà ò˜áâà äà èçòå…å îò ôèëòú˜à çà ãî˜èâî. æêî å íåîáõîäèìî,

çàäåéñòâàéòå ïîäêà…âàùàòà ïîìïà (C), çà äà èçòî…èòå âîäà, íî ñàìî äîêàòî

ïîòå…å ãî˜èâî îò ôèëòú˜à.

4. Çàòåãíåòå ï˜îáêàòà çà èçòî…âàíå.

5. Ñòà˜òè˜àéòå äâèãàòåë. ‡âå˜åòå ñå, …å ï˜åäóï˜åäèòåëíàòà ëàìïà çàãàñâà.

ﬁ˜îâå˜åòå ç à òå…îâå.

Êàê ñå ïðîâåðÿâà/ðåãóëèðà ðåìúêà íà

âåíòèëàòîðà - Ôèãóðà

Ïðîâåðÿâàíå íà ðåìúêà íà âåíòèëàòîðà

1. ﬁ˜îâå˜åòå ñúñòîíèåòî (A, ·èãó˜à 9). æêî ïî ˜åìúêà íà âåíòèëàòî˜à èìà

ïóêíàòèíè èëè å ïîâ˜åäåí, ñìåíåòå ãî ñ íîâ.

2. ﬁ˜îâå˜åòå îïúâàíåòî íà ˜åìúêà íà âåíòèëàòî˜à. ‹àòèñíåòå ñ˜åäàòà (C)íà

˜åìúêà íà âåíòèëàòî˜à. æêî îïúâàíåòî å ï˜àâèëíî, ñ˜åäàòà íà ˜åìúêà ùå ñå

ï˜åìåñòâà ñ 3/8 √ 1/2 èí…à (10 √ 12 mm) ï˜è ï˜èëàãàíå íà 22 ïàóíäà (10 kg)

ñèëà âú˜õó íå. æêî îïúâàíåòî å ñëàáî, ˜åãóëè˜àéòå ãî êàêòî ñëåäâà.

Ðåãóëèðàíå íà îïúâàíåòî íà ðåìúêà íà âåíòèëàòîðà

1. ˆàçõëàáåòå ìîíòà¥íèòå áîëòîâå íà àëòå˜íàòî˜à (D)è(E). ◊è¥òå ·èãó˜à 9.

2. ﬁîñòàâåòå ìîíòà¥íà ùàíãà (F) ñ˜åùó àëòå˜íàòî˜à (G) è ñò˜àíàòà íà áëîêà íà

äâèãàòåë. Çà äà îáòåãíåòå ˜åìúêà íà âåíòèëàòî˜à, èçòåãëåòå ìîíòà¥íàòà

ùàíãà. Çàòåãíåòå â˜åìåííî ìîíòà¥íèòå áîëòîâå íà àëòå˜íàòî˜à.

3. ﬁ˜îâå˜åòå îïúâàíåòî íà ˜åìúêà íà âåíòèëàòî˜à. ‹àï˜àâåòå ñï˜àâêà â ˜àçäåë

Ïðîâåðêà íà ðåìúêà íà âåíòèëàòîðà. æêî ñå íàëàãà, ïîâòî˜åòå ï˜îöåäó˜àòà.

4. Çàòåãíåòå ìîíòà¥íèòå áîëòîâå íà àëòå˜íàòî˜à.

Çàòåãíåòå áîëòà (D) ñ âú˜òùìîìåíòîò14ïàóíäôóòà(19Nm).

Çàòåãíåòå áîëòà (E) ñ âú˜òù ìîìåíò îò 45 ïàóíäôóòà (61 Nm).

Ñêëàäèðàíå

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ

Ãîðèâîòî è íåãîâèòå ïàðè ñà èçêëþ÷èòåëíî îãíåîïàñíè è

èçáóõëèâè.

Ïîæàð èëè âçðèâ ìîãàò äà ïðè÷èíÿò ñåðèîçíè îáãàðÿíèÿ èëè

ñìúðò.

Ïðè ñêëàäèðàíå íà ãîðèâî èëè íà ìàøèíà ñ ãîðèâî â ðåçåðâîàðà

• Ñêëàäè˜àéòå äàëå… îò ïåùè, ïå…êè, âîäîíàã˜åâàòåëè èëè ä˜óãè åëåêò˜è…åñêè

ï˜èáî˜è, êîèòî èìàò ñèãíàëíè ëàìïè èëè ä˜óãè çàïàëèòåëíè èçòî…íèöè,

çàùîòî òå ìîãàò äà âúçïëàìåíò èçïà˜åíèòà îò ãî˜èâîòî.

Ìàñëîòî íà äâèãàòåëÿ

Äîêàòî äâèãàòåëò å âñå îùå òîïúë ñìåíåòå ìàñëîòî.

Îòêðèâàíå è îòñòðàíÿâàíå íà íåèçïðàâíîñòè

‹ó¥äàåòå ëè ñå îò ïîìîù? ﬁîñåòåòå BRIGGSandSTRATTON.COM èëè ñå îáàäåòå

íà 1-800-233-3723.

BRIGGSandSTRATTON.COM

Òåõíè÷åñêè äàííè

Ñïåöèôèêàöèè çà äâèãàòåëÿ

ﬂîäåë 520000

ˆàáîòåí îáåì 51,87 in

(850 cm

)

◊úò˜åμåí äèàìåòú˜ íà öèëèíäú˜à 2,677 in (68 mm)

ˆàáîòåí õîä íà áóòàëîòî 3,071 in (78 mm)

◊ìåñòèìîñò çà ìàñëî 3,5 qt (3,3 L)

Ñïåöèôèêàöèè çà äâèãàòåëÿ

ﬂîäåë 580000

ˆàáîòåí îáåì 58,09 in

(953 cm

)

◊úò˜åμåí äèàìåòú˜ íà öèëèíäú˜à 2,835 in (72 mm)

ˆàáîòåí õîä íà áóòàëîòî 3,071 in (78 mm)

◊ìåñòèìîñò çà ìàñëî 3,5 qt (3,3 L)

Ðåãóëèðîâú÷íè äàííè *

ﬂîäåë 520000, 580000

ﬂå¥äèíà íà ñìóêàòåëíè êëàïàí

0,008 in (0,2 mm)

ﬂå¥äèíà íà èçïóñêàòåëíè êëàïàí

0,008 in (0,2 mm)

* ﬂîùíîñòòà íà äâèãàòåë íàìàëâà ñ 3,5% íà âñåêè 1000 ôóòà (300 ìåò˜à) íàä

ìî˜ñêîòî íèâî è ñ 1% çà âñåêè 10° F(5,6° C) íàä 77° F(25° C). Äâèãàòåëòùå

˜àáîòè çàäîâîëèòåëíî ï˜è íàêëîí äî 15°. ‹àï˜àâåòå ñï˜àâêà â ˆúêîâîäñòâîòî çà

˜àáîòà ñ îáî˜óäâàíåòî çà áåçîïàñíèòå ã˜àíèöè çà ˜àáîòà íà íàêëîíè.

Äà ñå ï˜îâå˜âà, êîãàòî äâèãàòåëò å ñòóäåí.

Îáèêíîâåíè ÷àñòè çà ïîääðúæêà n

Ñåðâèçíà ÷àñò Íîìåð íà ÷àñòòà

◊úçäóμåí ôèëòú˜ 820263

ﬂàñëåí ôèëòú˜ 820314

·èëòú˜ çà ãî˜èâî 820311

V-îá˜àçåí ˜åìúê (940 mm) 821075

V-îá˜àçåí ˜åìúê (970 mm) 820893

n ‹èå âè ï˜åïî˜ú…âàìå äà ïîñåòèòå íêîé îò ‡ïúëíîìîùåíèòå ï˜åäñòàâèòåëè

íà Briggs & Stratton çà âñè…êè îïå˜àöèè ïî òåõíè…åñêîòî è ñå˜âèçíîòî îáñëó¥âàíå

íà äâèãàòåë 3/LC è ˜åçå˜âíèòå …àñòè. ¤çïîëçâàéòå ñàìî î˜èãèíàëíè …àñòè íà

Briggs & Stratton.

ÃÀÐÀÍÖÈÎÍÍÀ ÏÎËÈÖÀ ÍÀ BRIGGS & STRATTON ÇÀ ÑÎÁÑÒÂÅÍÈÊ ÍÀ

3-ÖÈËÈÍÄÐÎÂ ÄÂÈÃÀÒÅË Ñ ÂÎÄÍÎ ÎÕËÀÆÄÀÍÅ 3/LC

Ìàé 2008 ã.

ÿî˜ïî˜àöè Briggs & Stratton ùå ˜åìîíòè˜à èëè çàìåíè áåçïëàòíî âñêà …àñò (âñè…êè …àñòè) íà äâèãàòåë, êîòî (êîèòî) å (ñà) ïîâ˜åäåíà(è), ïî˜àäè äåôåêòåí

ìàòå˜èàë èëè ï˜îèçâîäñòâî, èëè ïî˜àäè äâåòå. ‚˜àíñïî˜òíèòå ˜àçõîäè íà èçï˜àòåíèòå çà ˜åìîíò èëè ñìíà …àñòè ïî òàçè ãà˜àíöè ñå ïîåìàò îò êóïóâà…à.

‚àçè ãà˜àíöè å âàëèäíà çà îï˜åäåëåíè ñ˜îê è å ï˜åäìåò íà óñëîâèòà, ôèêñè˜àíè ïî-äîëó. Çà îáñëó¥ âàíå ïî ãà˜àíöèòà ñå îáú˜íåòå êúì íàé-áëèçêè

‡ïúëíîìîùåí ñå˜âèçåí ï˜åäñòàâèòåë çà äâèãàòåëèòå 3 /LC, êîéòî ìî¥å äà îòê˜èåòå â íàμè óêàçàòåë íà àä˜åñ BRIGGSandSTRATTON.COM, èëè êàòî

ñå îáàäèòå íà òåëåôîí 1-800-233-3723, èëè êàòî å ïîñî…åíî â «≠úëòèòå ñò˜àíèöèt».

Íÿìà äðóãà ñïåöèàëíà ãàðàíöèÿ. Ïîäðàçáèðàùèòå ñå ãàðàíöèè, âêëþ÷èòåëíî òåçè çà ãîäíîñòòà çà ïðîäàæáà èëè çà íÿêàêâà ñïåöèàëíà öåë, ñà

îãðàíè÷åíè äî åäíà ãîäèíà îò äàòàòà íà êóïóâàíå èëè äî ñðîêà, ðàçðåøåí ïî çàêîí, à âñè÷êè ñâúðçàíè ãàðàíöèè ñå èçêëþ÷âàò. Îòãîâîðíîñò çà

ñëó÷àéíè èëè ïîñëåäâàùè ùåòè ñå èçêëþ÷âà â ñòåïåí, ðàçðåøåíà ïî çàêîí. ‹êîè ùàòè èëè ñò˜àíè íå ïîçâîëâàò îã˜àíè…åíè çà â˜åìåò˜àåíåòî íà

ïîä˜àçáè˜àùàòà ñå ãà˜àíöè,àíêîè ùàòè èëè ñò˜àíè íå ïîçâîëâàò èçêë˚…âàíåòî èëè îã˜àíè…àâàíåòî íà ñëó…àéíè èëè ïîñëåäâàùè ùåòè, òàêà …å å

âúçìî¥íî ãî˜íîòî îã˜àíè…åíèå è èçêë˚…åíèå äà íå âà¥è çà âàñ. ‚àçè ãà˜àíöè âè äàâà ñïåöèôè…íè çàêîíîâè ï˜àâà, à âèå ìî¥åòå äà èìàòå è ä˜óãè òàêèâà,

êîèòî ñå èçìåíò â åäèí èëè ä˜óã ùàò, èëè â åäíà èëè ä˜óãà ñò˜àíà.

ÎÃÐÀÍÈ×ÅÍÀ ÃÀÐÀÍÖÈß

ÍÀØ ÏÐÎÄÓÊÒ

Ãàðàíöèîíåí ïåðèîä

Äâèãàòåë Vanguardt 3/LC Ãàðàíöèÿ çà îñíîâíè ÷àñòè * Ðåçåðâíè ÷àñòè è âëàãàí òðóä *

Çà ëè…íî è òú˜ãîâñêî ïîëçâàíå

2 ãîäèíè

3 ãîäèíè 2 ãîäèíè

* Îòáåëåæåòå ñëåäíèòå ñïåöèàëíè ãàðàíöèîííè ïåðèîäè: Çà öåëèòå íà òàçè ãà˜àíöèîííà ïîëèòèêà, ïîê˜èòèåòî çà ˜åçå˜âíèòå …àñòè è âëàãàíèò

çà çàìíàòà èì ò˜óä å çà ïå˜èîä îò 2 ãîäèíè. Ñàìî çà îñíîâíèòå ˜åçå˜âíè …àñòè ãà˜àíöèîííîòî ïîê˜èòèå å ˜àçμè˜åíî è çà ò˜åòàòà ˜àáîòíà

ãîäèíà. Ãàðàíöèÿòà çà îñíîâíèòå ÷àñòè (Ã.Î.×) ïîêðèâà, íî íå ñå îã˜àíè…àâà åäèíñòâåíî è ñàìî äî öèëèíä˜îâè áëîê, öèëèíä˜îâàòà ãëàâà,

êîëåí…àòè âàë, ˜àçï˜åäåëèòåëíè âàë, çúáíèòå ï˜åäàâêè, áóòàëàòà, ìîòîâèëêèòå, ìàõîâèêà, êî¥óõà çà ìàõîâèêà, ìàñëåíàòà ïîìïà,

âåíòèëàòî˜à, ˜åìú…íèòå μàéáè, ìåõàíè…íè ˜åãóëàòî˜, ñìóêàòåëíè êîëåêòî˜ è ìàñëåíè êà˜òå˜. Ã.Î.× íå ïîêðèâà èíåñåîã˜àíè…àâà

åäèíñòâåíî è ñàìî çà áóòàëíèòå ñåãìåíòè, ñìåíåìèòå ëàãå˜è, âîäíàòà ïîìïà, âñåêè åëåìåíò îò åëåêò˜è…åñêàòà èíñòàëàöè, çàäâè¥âàùèòå

åëåìåíòè çà êëàïàíèòå, ñïîìàãàòåëíèòå …àñòè, óïëúòíåíèòà, ãà˜íèòó˜èòå, êà˜áó˜àòî˜èòå, êîëåêòî˜à çà èçãî˜åëèòå ãàçîâå, ãúâêàâèòå ï˜îâîäè,

âñè…êè åëåìåíòè íà ãî˜èâíàòà ñèñòåìà, ˜àçï˜úñêâàùèòå ä˚çè, íàãíåòàòåëíàòà ïîìïà, òó˜áîêîìï˜åñî˜à, μóìîçàãëóμèòåë, âñè…êè ôèëò˜è,

˜àäèàòî˜à, òå˜ìîñòàòà, çàïàëèòåëíèòå ñâåùè, íàã˜åâàòåëíèòå ñâåùè è ïîìïèòå çà ïîäàâàíå íà ãî˜èâî. øà˜àíöèîííèò ïå˜èîä çàïî…âà îò äàòàòà

íà êóïóâàíå îò ïú˜âè ïîò˜åáèòåë íà ä˜åáíî èëè îò êóïóâà…à çà òú˜ãîâñêè öåëè è ï˜îäúë¥àâà çà ïå˜èîäà îò â˜åìå, ôèêñè˜àí â ãî˜íàòà òàáëèöà.

Íå å íåîáõîäèìà ðåãèñòðàöèÿ íà ãàðàíöèÿòà, çà äà ñå ïîëó÷è ãàðàíöèîííî îáñëóæâàíå çà ïðîäóêòèòå íà Briggs & Stratton. Ïàçåòå çà äîêàçàòåëñòâî

êâèòàíöèÿòà îò ïîêóïêàòà. Àêî íå îñèãóðèòå äîêàçàòåëñòâî çà íà÷àëíàòà äàòà íà êóïóâàíå, ïðè ïîèñêâàíå íà ãàðàíöèîííî îáñëóæâàíå, äàòàòà íà

ïðîèçâîäñòâî íà ïðîäóêòà ùå áúäå èçïîëçâàíà çà îïðåäåëÿíå íà ãàðàíöèîííèÿ ïåðèîä.

Îòíîñíî âàøàòà ãàðàíöèÿ

Briggs & Stratton ï˜èåìàò ñ ãîòîâíîñò ãà˜àíöèîííè ˜åìîíò è ñå èçâèíâàò çà

ï˜è…èíåíîòî âè íåóäîáñòâî. ◊ñåêè ›òî˜èçè˜àí ñå˜âèçåí ï˜åäñòàâèòåë íà Briggs

& Stratton ìî¥å äà îñúùåñòâè ãà˜àíöèîííèòå ˜åìîíòè íà äâèãàòåëèòå 3/LC.

ﬁîâå…åòî ãà˜àíöèîííè ˜åìîíòè ñå ï˜îâå¥äàò ˜óòèííî, íî ïîíêîãà å âúçìî¥íî

èñêàíèòà çà ãà˜àíöèîííî ñå˜âèçíî îáñëó¥âàíå äà íå ñà îï˜àâäàíè. ‹àï˜èìå˜,

ãà˜àíöè íìà äà ñå ï˜èçíàå, àêî ïîâ˜åäàòà â äâèãàòåë ñå äúë¥è íà íåï˜àâèëíà

óïîò˜åáà, íà ëèïñà íà ˜åäîâíî òåõíè…åñêî îáñëó¥âàíå, íà íåï˜àâèëíî

ò˜àíñïî˜òè˜àíå, ìàíåâ˜è˜àíå è ñêëàäè˜àíå èëè íà íåêà…åñòâåí ìîíòà¥. Ñúùî

òàêà, ãà˜àíöèòà ñå ãóáè, àêî ñå˜èéíèò íîìå˜ íà äâèãàòåë å îòñò˜àíåí èëè ñà

ï˜àâåíè ï˜îìåíè ïî ñàìè äâèãàòåë.

æêîêóïóâà…úòíååñúãëàñåíñ˜åμåíèåòî íà Ñå˜âèçíè ï˜åäñòàâèòåë, ùå ñå

íàï˜àâè ï˜îó…âàíå, çà äà ñå óñòàíîâè äàëè ãà˜àíöèòà ñå ï˜èçíàâà. ¤çèñêâàéòå

îò Ñå˜âèçíè ï˜åäñòàâèòåë äà ï˜åäîñòàâè çà ï˜åãëåä âñè…êè äîïúëíèòåëíè

ôàêòè íà ñâî äèñò˜èáóòî˜ èëè íà çàâîäà. æêî äèñò˜èáóòî˜úò èëè çàâîäúò ˜åμè,

…å òîâà èñêàíå å îï˜àâäàíî, êóïóâà…úò ùå áúäå íàïúëíî îáåçùåòåí çà

äåôåêòíèòå …àñòè. Çà äà ñå èçáåãíå íåäî˜àçóìåíèåòî, êîåòî ìî¥å äà âúçíèêíå

ìå¥äó êóïóâà…à è ï˜åäñòàâèòåë, ïî-äîëó ñà èçá˜îåíè íêîè îò ï˜è…èíèòå çà

ïîâ˜åäà â äâèãàòåë, êîèòî ãà˜àíöèòà íå ïîê˜èâà.

Íîðìàëíî èçíîñâàíå: Äâèãàòåëèòå, êàêòî âñè…êè ìåõàíè…íè óñò˜îéñòâà, ñå

íó¥äàò îò ïå˜èîäè…íà çàìíà íà …àñòè è îáñëó¥âàíå, çà äà ˜àáîòò äîá˜å.

øà˜àíöèòà íå ïîê˜èâà ˜åìîíòà, êîãàòî ï˜è íî˜ìàëíî èçíîñâàíå äàäåíà …àñò èëè

äâèãàòåëò ñà èç…å˜ïàëè ¥èâîòà ñè. øà˜àíöèòà íå ñå ï˜èëàãà, àêî â äâèãàòåë ñå

ñëó…è ïîâ˜åäà, ïî˜àäè íåï˜àâèëíî ïîëçâàíå èëè îòñúñòâèå íà ˜óòèííà

ïîää˜ú¥êà, ò˜àíñïî˜òè˜àíå, ìàíèïóëè˜àíå, ñúõ˜àíâàíå èëè íåï˜àâèëåí

ìîíòà¥. Ñúùî òàêà, ãà˜àíöèòà ñå ãóáè, àêî ñå˜èéíèò íîìå˜ íà äâèãàòåë å

îòñò˜àíåí èëè ïî íåãî ñà ï˜àâåíè ï˜îìåíè.

Íåïðàâèëíî ïîääúðæàíå: ≠èâîòúò íà äàäåí äâèãàòåë çàâèñè îò óñëîâèòà, ï˜è

êîèòî ˜àáîòè è îò ã˜è¥èòå, êîèòî ïîëó…àâà. ‹êîè ï˜èëî¥åíè, êàòî

êóëòèâàòî˜è, ïîìïè, è ˜îò àöèîííè êîñà…êè, ìíîãî …åñòî ñå èçïîëçâàò â ï˜àμíà è

çàìú˜ñåíà ñ˜åäà, êîåòî ìî¥å äà äîâåäå äî ï˜åäâà˜èòåëíîòî èì èçíîñâàíå.

‚àêîâà èçíîñâàíå íå ñå ïîê˜èâà îò ãà˜àíöèòà, êîãàòî ñå äúë¥è íà ì˜úñîòè,

ï˜àõ, àá˜àçèâ çà ïî…èñòâàíå íà ñâåùòà èëè ä˜óãè àá˜àçèâíè ìàòå˜èàëè,

ïîïàäíàëè â äâèãàòåë ïî˜àäè íåêà…åñòâåíî ïîääú˜¥àíå.

Òàçè ãàðàíöèÿ ïîêðèâà ñàìî

óïîòðåáåí â äâèãàòåëÿ äåôåêòåí ìàòåðèàë

è/èëè èçðàáîòêà, à íå çàìÿíàòà èëè âúçñòàíîâÿâàíåòî íà ìàøèíàòà, êúì

êîÿòî äâèãàòåëÿò ìîæå äà áúäå ìîíòèðàí. Ãàðàíöèÿòà íå ïîêðèâà è

ïîèñêàíè ðåìîíòè ïîðàäè:

1 Äâèãàòåëè, êîèòî íå ñà ï˜àâèëíî ìîíòè˜àíè êúì çàäâè¥âàíàòà ìàμèíà.

‹àñòîé…èâî ñå ï˜åïî˜ú…âà ï˜åäâà˜èòåëíî äà ñå îáú˜íåòå êúì çàâîäà, êîãàòî

ùå ìîíòè˜àòå 3-öèëèíä˜îâ äâèãàòåë ñ âîäíî îõëà¥äàíå B&S 3/LC êúì

ìàμèíà, êîòî íå èçïîëçâà, ïî íà…àëî, äâèãàòåë B&S 3/LC.

2 Ïðîáëåìè, ïðè÷èíåíè îò ÷àñòè, êîèòî íå ñà îðèãèíàëíè ÷àñòè íà Briggs &

Stratton.

3 ‡ñò˜îéñòâà çà óï˜àâëåíèå íà ìàμèíàòà èëè ñúî˜ú¥åíè, êîèòî ï˜å…àò íà

ñòà˜òè˜àíåòî íà äâèãàòåë, âîäò äî íåçàäîâîëèòåëíàòà ìó ˜àáîòà èëè

ñêúñâàò ¥èâîòà ìó. (ÿîíñóëòè˜àéòå ñå ñ ï˜îèçâîäèòåë íà óñò˜îéñòâàòà.)

4 ÿà˜áó˜àòî˜è ñ òå…îâå, çàä˜úñòåíè ï˜îâîäè èëè ˜àçï˜úñêâàùè ä˚çè çà

ãî˜èâîòî, çàëåïíàëè êëàïàíè, çàìú˜ñåíè íàãíåòàòåëíè ïîìïè èëè ä˜óãà

ïîâ˜åäà, ï˜è…èíåíà îò çàìú˜ñåíî èëè ï˜åñòîëî ãî˜èâî. ‡ïîò˜åáâàéòå

…èñòî, ï˜ñíî ãî˜èâî (áåíçèí áåç ñúäú˜¥àíèå íà îëîâî, äèçåëîâî ãî˜èâî) è

ñòàáèëèçàòî˜ íà ãî˜èâî Briggs & Stratton ñ êàòàëî¥åí No 5041.

5 ˝àñòè, êîèòî ñà íàä˜àíè èëè ñ…óïåíè, çàùîòî äâèãàòåëò å ˜àáîòèë ñ

íåäîñòàòú…íî èëè çàìú˜ñåíî ìàñëî, èëè ñ ìàñëî ñ íåïîäõîäùî êà…åñòâî

(ﬁ˜îâå˜âàéòå å¥åäíåâíî íèâîòî íà ìàñëîòî èëè ñëåä âñåêè 8 …àñà ˜àáîòà.

ÿîãàòî å íåîáõîäèìî, äîëèâàéòå è ñìåíéòå ìàñëîòî è ìàñëåíè ôèëòú˜ íà

ï˜åïî˜ú…âàíèòå èíòå˜âàëè îò â˜åìå). æâà˜èéíîòî óñò˜îéñòâî OIL GARD

ìî¥å äà íå ñï˜å ˜àáîòåùè äâèãàòåë. æêî íèâîòî íà ìàñëîòî íå ñå ïîääú˜¥à

òî…íî, äâèãàòåëò ìî¥å äà ñå ïîâ˜åäè. ﬁ˜î…åòåòå ˆúêîâîäñòâîòî çà ˜àáîòà.

6 ˆåìîíò èëè ˜åãóëè˜àíå íà ìîíòè˜àíè …àñòè èëè àã˜åãàòè êàòî ñúåäèíèòåëè,

ï˜åäàâàòåëíè ìåõàíèçìè, äèñòàíöèîííè óï˜àâëåíè èä˜.,êîèòîíåñà

ï˜îèçâåäåíè îò Briggs & Stratton.

7 ﬁîâ˜åäà èëè èçíîñâàíå íà …àñòè, ï˜è…èíåíè îò íå…èñòîòè, ïîïàäíàëà â

äâèãàòåë, ïî˜àäè íåêà…åñòâåíî ïîääú˜¥àíå íà âúçäóμíè ôèëòú˜,

íåêà…åñòâåí ïîâòî˜åí ìîíòà¥ èëè îò èçïîëçâàíå íà íåî˜èãèíàëíè åëåìåíòè

çà ôèëòú˜à. ‹à ï˜åïî˜ú…âàíèòå èíòå˜âàëè îò â˜åìå ïî…èñòâàéòå è/èëè

ñìåíâàéòå ôèëòú˜à, êàêòî å ïîñî…åíî â ˆúêîâîäñòâîòî çà ˜àáîòà.

8 ˝àñòè, ïîâ˜åäåíè ïî˜àäè íàäâèμ

åíè ìàêñèìàëíè îáî˜îòè èëè ïî˜àäè

ï˜åã˜âàíå, äúë¥àùî ñå íà ò˜åâè, íàñëîâàíè èëè çàìú˜ñâàíå, êîèòî

çàïóμâàò, çàä˜úñòâàò ˜àäèàòî˜à èëè îòâî˜èòå çà äîñòúï íà îõëà¥äàùè

âúçäóõ, èëè ïîâ˜åäà, äúë¥àùà ñå íà ˜àáîòà â çàòâî˜åíî ï˜îñò˜àíñòâî ñ

íåäîñòàòú…íà âåíòèëàöè. ﬁîâ˜åäà íà äâèãàòåë, äúë¥àùà ñå íà

íåñïàçâàíåòî íà òî…íîòî ñúîòíîμåíèå íà àíòèô˜èç è ïèòåéíà âîäà èëè íà

ï˜îíèêâàíåòî íà âîäà â íåãî ïî íêàêâà ï˜è…èíà.

9 ˝àñòè íà äâèãàòåë èëè ìàμèíàòà, ñ…óïåíè îò ï˜åêîìå˜íà âèá˜àöè,

äúë¥àùà ñå íà õëàáàâ ìîíòà¥ íà äâèãàòåë, õëàáàâè ˜ å¥åùè íî¥îâå,

õëàáàâè ïëàñòèíè è õëàáàâè èëè çëå áàëàíñè˜àíè ˜àáîòíè êîëåëà, íà

íåäîá˜î êóïëè˜àíå íà ìàμèíàòà êúì êîëåí…àòè âàë íà äâèãàòåë,íà

ñâ˜úõâèñîêè îáî˜îòè èëè ä˜óãà çëîóïîò˜åáà ï˜è ˜àáîòà.

10 ˆóòèííà íàñò˜îéêà è ˜åãóëè˜îâêà íà äâèãàòåë.

11 ﬁîâ˜åäà íà äâèãàòåë èëè íà íåãîâ åëåìåíò, ò.å. ãî˜èâíà êàìå˜à, êëàïàíè,

êëàïàííè ëåãëà, êëàïàííè âîäà…è, èëè èçãî˜åëè íàìîòêè íà ñòà˜òå˜à ïî˜àäè

èçïîëçâàíåòî íà àëòå˜íàòèâíè ãî˜èâà êàòî íàôòà, ï˜è˜îäåí ãàç, áåíçèíè ñ

ï˜îìåíåíè êà…åñòâà è ò.í.

Ãàðàíöèîííîòî ñåðâèçíî îáñëóæâàíå å äîñòúïíî åäèíñòâåíî ÷ðåç

Îòîðèçèðàíèòå ñåðâèçíè ïðåäñòàâèòåëè íà Êîðïîðàöèÿ Briggs & Stratton.

Íàìåðåòå íàé-áëèçêèÿ Îòîðèçèðàí ñåðâèçåí ïðåäñòàâèòåë çà äâèãàòåëèòå

3/LC â íàøàòà óêàçàòåëíà êàðòà çà ïðåäñòàâèòåëèòå íà àäðåñ

BRIGGSandSTRATTON.COM, èëè êàòî ñå îáàäèòå íà òåë. 1-800-233-3723, èëè

êàêòî å ïîñî÷åíî â „Æúëòèòå ñòðàíèöèt”.

20 BRIGGSandSTRATTON.COM

Všeobecné informace

Potøebujete-li náhradní díly nebo technickou pomoc, zapište dolù model motoru, typové a

kódové èíslo a datum nákupu. Tato naleznete na svém motoru (viz kapitola Funkce a

ovládací prvky).

Datum nákupu:

Model motoru:

DD/MM/RRRR

Model: Kód:Typ:

Informace o jmenovitém výkonu motoru

U motorù 3/LC je hrubý výkon motoru uvádìn v souladu s kritérii normy SAE J1995 a

èistý výkon motoru v souladu s kritérii normy SAE J1349. Skuteèný výkon produkèních

motorù nainstalovaných v konkrétních zaøízeních se mùže lišit v závislosti na mnoha

faktorech, vèetnì omezení otáèek motoru (RPM) pøi daném použití, podmínek životního

prostøedí, údržby motoru/zaøízení a dalších promìnných.

Bezpeènost obsluhy

Výbuch

Toxické výparyPohyblivé èásti

Úraz elektrickým

proudem

Horký povrch

Zpìtný ráz

Požár

Uzávìr paliva

Ètìte návod

Sytiè

Olej

Palivo

Zapnuto/Vypnuto

Stop

Používejte

ochranu zraku

Pomalu

Rychle

BEZPEÈNOSTNÍ A KONTROLNÍ SYMBOLY

Nebezpeèná

chemikálie

Omrzlina

Horká kapalina

nebo pára

Symbol bezpeènostního upozornìní

oznaèuje bezpeènostní informace týkající se

rizik, který mohou zpùsobit úraz. Signální slovo (NEBEZPEÈÍ, UPOZORNÌNÍ nebo

VÝSTRAHA) se používá spolu s varovným symbolem pro vyznaèení pravdìpodobnosti a

potenciální vážnosti úrazu. Mimo to mùže být pro oznaèení druhu nebezpeèí použit symbol

nebezpeèí.

NEBEZPEÈÍ vyznaèuje ohrožení, které, není-li eliminováno, zpùsobí smrt

nebo vážný úraz.

VAROVÁNÍ vyznaèuje ohrožení, které, není-li eliminováno, mùže zpùsobit

smrt nebo vážný úraz.

POZOR oznaèuje ohrožení, které, není-li eliminováno, mùže zpùsobit lehký,

nebo støednì tìžký úraz.

POZOR, pokud se použije bez varovného symbolu, oznaèuje situaci, vnížby

mohlo dojít k poškození produktu.

Výfukové plyny tohoto výrobku obsahují chemikálie, o nichž je ve

státì Kalifornie známo, že zpùsobují rakovinu, poškození plodu èi jiné

poruchy reprodukce.

VAROVÁNÍ

Briggs & Stratton neschvaluje ani nepovoluje použití tìchto motorù

na tøíkolových terénních vozidlech (ATV), motocyklech,

zábavních/rekreaèních motokárách, letadlech nebo vozidlech

urèených pro sportovní soutìže. Takové použití tìchto motorù by

mohlo vést ke škodám na majetku, vážnému zranìní (vèetnì

ochrnutí) nebo i ke smrtelnému úrazu.

VAROVÁNÍ

POZOR: Tento motor byl odeslán spoleèností Briggs & Stratton bez oleje. Než motor

nastartujete, ještì jednou zkontrolujte, zda jste doplnili olej podle pokynù uvedených v

této pøíruèce. Jestliže nastartujete motor bez oleje, poškodí se tak, že už nepùjde opravit

a nebude kryt žádnou zárukou.

VAROVÁNÍ

Benzin a jeho páry jsou vysoce hoølavé a výbušné.

Požár nebo výbuch mùže zpùsobit vážné popáleniny nebo i smrt

Když doplòujete palivo

• Vypnìte motor a pøed sejmutím uzávìru palivové nádrže jej n echte nejménì 2

minuty chladnout.

• Nádrž plòte venku nebo v dobøe vìtraném prostoru.

• Nepøeplòujte palivovou nádrž. Nádrž plòte zhruba 38 mm (1,5 palce) pod horní

okraj hrdla kvùli tepelné roztažnosti paliva.

• Benzín chraòte pøed jiskrami, otevøeným ohnìm, vìènými plamínky, horkem a

jinými zdroji vznícení.

• Kontrolujte palivové potrubí, nádrž a uzávìr a všechny spoje na tìsnost a

praskliny. V pøípadì potøeby proveïte výmìnu.

• Jestliže rozlijete palivo, poèkejte, až se odpaøí a teprve potom spuste motor.

Pøi spouštìní motoru

• Zkontrolujte, zda jsou na svém místì svíèky, tlumiè výfuku, víèko palivové nádrže a

vzduchový filtr (je-li jím motorvybaven), a zda jsou dobøe zajištìny.

• Neotáèejte motorem pøi odstranìné svíèce.

• Pøi pøeplavení motoru nastavte sytiè (je-li k dispozici) do polohy OPEN/RUN (chod)

a škrtící klapku do polohy FAST (rychle) a protáèejte motor, dokud nenaskoèí.

Pøi obsluze zaøízení

• Nenaklánìjte motor ani zaøízení do polohy, která by zpùsobila únik benzínu.

• Motor se nesmí zastavovat zahlcením karburátoru.

• Nespouštìjte ani neprovozujte motor s odmontovanou sestavou vzduchového filtru

(je-li jím motor vybaven) nebo s vyjmutým vzduchovým filtrem (je-li jím motor

vybaven).

Pøi výmìnì oleje

• když vypouštíte olej z horní plnící olejové trubky, musí být palivová nádrž prázdná,

protože jinak mùže palivo unikat z nádrže a zpùsobit požár nebo explozi.

Pøi pøepravì zaøízení

• Zaøízení pøepravujte s PRÁZDNOU palivovou nádrží nebo zavøeným palivovým

kohoutem.

Pøi skladování benzínu nebo zaøízení s palivem v nádrži

• Uchovávejte oddìlenì od pecí, kamen, ohøívaèù vody èi jiných zaøízení, která mají

vìèný plamínek nebo od jiných zdrojù zapálení. Mohou zažehnout benzinové páry.

Spouštìní motoru je doprovázené jiskøením.

Jiskøení mùže zažehnout pøítomné hoølavé plyny.

Výsledkem mùže být požár nebo výbuch.

VAROVÁNÍ

• Nespouštìjte motor, uniká-li v prostoru zemní plyn nebo propan-butan (LPG).

• Nepoužívejte stlaèené startovací kapaliny, jejich páry jsou hoølavé.

Motory produkují oxid uhelnatý, což je bezbarvý jedovatý plyn bez

zápachu.

Vdechování oxidu uhelnatého mùže zpùsobit nevolnost, mdloby až smrt.

VAROVÁNÍ

• Spouštìjte a provozujte motor venku.

• Nespouštìjte ani neprovozujte motor v uzavøeném prostoru, i když jsou otevøená

okna i dveøe.

Pagina se încarcă ...

Briggs & Stratton Vanguard 520000 Manualul proprietarului

Marca: Briggs & Stratton

Model: Vanguard 520000

Categorie: Accesorii pentru autovehicule

Tip: Manualul proprietarului

Descărcați PDF

raport

în alte limbi

slovenčina: Briggs & Stratton Vanguard 520000 Návod na obsluhu
eesti: Briggs & Stratton Vanguard 520000 Omaniku manuaal
italiano: Briggs & Stratton Vanguard 520000 Manuale del proprietario

Lucrări conexe

Simplicity 135202-1003-E1 Manual de utilizare

Briggs & Stratton Vanguard 520000 Manualul proprietarului

Briggs & Stratton Vanguard 520000 Manualul proprietarului

în alte limbi

Lucrări conexe

Alte documente