Wellis Cherokee Silver Quintet Manual de utilizare

Cherokee Quintet

WB00379

WB00380

EN

DE

FR

HU

RO

Cherokee Silver + Black Quintet 5 égős grill

SZERELÉSI ÚTMUTATÓ

Cherokee Silver + Black Quintet 5 arzătoare pe grătar pe gaz

INSTRUCȚIUNI DE MONTARE

Cherokee Silver + Black Quintet gril à gaz 5 feux

GUIDE D’INSTALLATION

Cherokee Silver + Black Quintet 5 Brenner Gasgrill

AUFBAUANLEITUNG

Cherokee Silver + Black Quintet 5 burners gas grill

ASSEMBLY MANUAL

SB-SG6295-01

16 x 4 x

2 x

5 x

4 x 4 x

2 x

6 x

2 x

1 x

4 x

2 x 8 x

4 x

4 x 4 x

8 x

6 x

2 x 2 x

2 x

1 x

Main burners

Hauptbrenner

Brûleurs principaux

Fő égők

Arzătoare principale

Side burner

Seitenbrenner

Brûleur latéral

Oldalégő

Arzător lateral

EN SAVE THESE INSTRUCTIONS

FOR FUTURE REFERENCE

THIS GAS GRILLS IS DESIGNED FOR

OUTDOOR USE ONLY

IMPORTANT: READ ALL INSTRUCTIONS AND OPERATIONS BE-

FORE OPERATING THIS UNIT. FOLLOW ALL STEPS IN ORDER.

NEVER ALLOW CHILDREN TO OPERATE THIS UNIT.

Warnings:

Only to be used outdoors. Read the instructions before using the appli-

ance. Accessible parts maybe very hot, keep young children away. Do

not move the appliance during use. Turn off the gas supply at the gas

cylinder after use. Any modication of the appliance may be danger-

ous. Parts sealed by the manufacturer or his agent must not be altered

by the user. Do not modify the appliance.

Attention:

Some parts of this appliance become very hot, take special care when

children or elderly are present.

For your safety:

Do not store or use gasoline or mentholated fuels or any other am-

mable vapors and liquids in the vicinity of this or any other appliance.

Never light a gas grill with gasoline or comparable uids!

Suggestion: user should not change the assembly that the manufactur-

er packaged.

Certain Liquid gas dealers may ll liquid gas cylinders for use in the

grill beyond cylinder lling capacity. This “Overlling” may create a dan-

gerous condition. “Overlling” tanks can build up excess pressure. As

a safety device, the tanks pressure relief valve will vent gas vapor to

relieve this excess pressure. This vapor is combustible and therefore

can be ignited. To reduce this danger, you should take the following

safety precautions:

A. When you have your tank lled, be sure you tell the supplier to ll it

to no more than 80% of its total capacity.

B. If you own or use an extra spare tank, or have a disconnected tank,

you should never store it near or under the grill unit or heat box, or

near any other ignition or heat source.

USE AND CHARACTERISTICS

The barbecue grill is safe and easy to use. Please ensure you only use your

barbecue at the correct pressure the appliance is designed for.

Food can be barbecued on the cooking grid either with or without the lid being

closed. When the lid is closed for 5 minutes, the lid must be open for 1 minute

to release heat.

Adequate ventilation is vital for combustion and efciency performance of the

barbecue. This will ensure the safety of the user and other people in the vicin-

ity of the area where the appliance is being used. Never use the appliance in

any enclosed covered area.

When the wind speed is above 2m/s, don’t use gas grill facing to the

wind. The appliance is designed for use outdoors only. Warning! Ac-

cessible parts may be very hot. Keep young children away. Read the

instructions before using the appliance. Do not move the appliance while

in use. Turn off the appliance at the cylinder valve or regulator after use.

Any modication to the appliance may be dangerous and may cause

injury or property damage. The parts sealed by the manufacturer or his

agent shall not be manipulated by the user. Any unauthorised modica-

tion of the appliance will invalidate the guarantee on this appliance. Do

not modify the appliance Never mount the cylinder under the barbecue

on the base shelf as this could result in serious injury to the user, other

people and/or property. Use protective gloves when handling particularly

hot components.

The appliance must not have any overhead obstruction. E.g. trees, shrubs,

lean to roofs. The appliance must be installed with a clearance of 1 m around

the appliance. The appliance must not be used near ammable materials.

(Petroleum based products, thinners or any other solid object that carries a

ammable warning label.) Close the valve of the gas cylinder or the regulator

after use. The use of this appliance in enclosed areas can be dangerous and

is prohibited.

EN 1. Technical data

a) Choose the proper regulator according to appliance category and

gas pressure in the table above, for example, Use 37mbar regulator

with appliance category I3+ for propane gas.

b) Marking on injector, for example,0.75 indicates that the size of the

injector is 0.75mm.

Remark: Allow to put a pan on the side burner. (The diameter of

pan is max Ф24cm and min Ф8cm)

2. Mounting steps

Make sure your grill is assembled properly. Detailed assembly instruc-

tions are packed with each grill giving specic assembly procedures for

each model. Follow these instructions carefully to ensure the correct

and safe assembly of the grill. Caution: Although we take every effort

to ensure that the assembly process is as easy as possible, it is inher-

ent with fabricated steel parts that corners and edged can cause cuts

if improperly handled during assembly procedures. Be careful while

handling any parts during assembly. It is strongly recommended that

you protect hands with a pair of work gloves.

Country of destination Appliance

category

Gas and supply

pressure

Main

burner

Side

burner

Appliance name

SB-SG6295-01

Injector

size Ø

Injector

size Ø

Total nominal

heat input (Hs)

BE, CH, CY, CZ, ES, FR, GB,

GR, IE, IT, LT, LU, LV, PT,

SK, SI

I3+(28-30/37)

Butane (G30) 28-

30 mbar

0.86 mm 0.76 mm 17.5kW 1272g/h

Propane (G31) 37

mbar

0.86 mm 0.76 mm 17.5kW 1248g/h

BE, CY, DK, EE, FI, HU, LT, NL,

NO, SE, SI, SK, RO, HR, TR,

BG, LU, MT I3B/P(30)

Butane/Propane

30 mbar

0.86 mm 0.76 mm 17.5kW 1272/h

AT, CH, DE, SK

I3B/P(50)

Butane/Propane

50 mbar

0.75 mm 0.66 mm 17.5kW 1272/h

PL

I3B/P(37)

Butane/Propane

37 mbar

0.82 mm 0.66 mm 17.5kW 1250/h

Use outdoors only.

Read the instructions before using the appliance. The gas cilinder

should not be placed inside BBQ.

WARNING: accessible parts may be very hot. Keep young

children away.

0063-21

Made in China

3. Preparation

You will need LPG gas bottle and proper regulators under the gas pressure

to operate this gas grill. The regulators should be comply with EN12864 with

current version and national regulation. See point 6 for farther instructions.

Energy saving tips:

a) Reduce the opening time of the lid.

b) Turn the grill off as soon as cooking is completed.

c) Preheat the gas grill for 10 to 15 minutes only. (Except for the rst use)

d) Do not preheat longer then recommended.

e) Do not use a higher setting than required.

f) Connect the hose and regulator to the gas container at the left side of the

gas grill .Keeping in mind that the gas container must be kept away from heat

and in a safe position .The hose dimension is 8-10mm diameter. The Length

of hose recommended which shall not exceed 1.5m.

4. Installation

After purchasing your gas cylinder you will then be ready to set it up with your

gas grill.

a) When changing the gas cylinder which shall be carried out away from any

source of ignition. Position the gas cylinder at left side or inside of your

BBQ, keeping in mind that the bottle must be kept away from heat and in a

safe position.

b) When ready to use your gas grill insert the regulator into the gas bottle

valve and tighten rmly.

Warning: Before attempting to light your gas grill you must refer to your

lighting instructions and warning / safety points. Check the hose before each

use, searching for cracking, cuts or any abrasions. If the hose is found to be

faulty in any way do not attempt to use your gas grill. When changing your gas

bottle ensures that there are no sources of ignition close by i.e. res, ciga-

rettes, naked ames etc. Make sure that the appliance is switched off.

Ensure that the hose is not subjected to twisting which will affect the gas ow

when installing your gas grill. Also the hose must not have undue tension and

must not touch any part of the gas grill which may be hot.

Please choose exible hose whose heatproof higher than 80°C Flexible tube

should be changed every 2 years; It’s necessary to change the exible tube

when the national conditions require it. How to change your cylinder

Note: Turn off the switch of cylinder (No spanner is required)

A) if put the gas cylinder outside the grill, The height of the gas cylin-

der is below the 80cm, and the width is within 35cm,Net weight of gas

cylinder should not be more than 15KG;

EN

Figure 1

How to connect a gas bottle

a) Turn the orange cap so that the arrow is pointing to the gap in the

shroud.

b) Remove the orange safety cap by pulling the lanyard out, then out.

Do not use tools. Leave the cap hanging.

c) Check that the black sealing washer is tted inside the cylinder

valve. Connect the regulator to the valve.

d) Turn the switch clockwise on gas bottle-then turn on the gas grill as

instructed.

Hose

Gas Connector Hose

Illustration for the connection of

BBQ and Hose

Gas Cylinder Regulator

Illustration for the connection of Gas

Cylinder, Regulator and Hose

Figure 2

Warning: Always test gas line for leaks at connector with soap water

nishing all connections.

How to disconnect a gas bottle

a) Except for twin-cylinder installations with a changeover valve, turn

off the gas tap if tted to the appliance. Wait until the burner and pilot

light have gone out. For installations with a changeover valve, it is only

necessary to switch off the empty cylinder.

b) Replace the orange safety cap onto the empty cylinder.

5. Warning and safety points

Please read the following points before using your gas grill:

a) Read the instructions before using the appliance. If instructions are not

followed it may cause problems in use.

b) This gas grill accessible parts maybe very hot when being used. Keep young

children away. Use protective when handling particularly hot components.

c) In the event of a gas leak, Turn off the gas supply at the gas bottle, extin-

guish any open ames, open lid and if leak continues, check for damages,

poor connections etc. Contact your local gas dealer immediately if the problem

can’t be solved.

d) Do not move Gas grill during use.

e) Do not use or store any liquids, vapors or other materials in the vicinity

when operating the gas grill.

f) This gas grill only to be used outdoors. g) Do not use a naked ame to

check for gas leaks. h) Do not operate gas grill if there is a gas leak. Turn off

the gas supply.

i) Do not attempt to disconnect any gas tting part if your gas grill is being

used, on the gas grill or the gas regulator / bottle.

j) Care is advised when operating your gas grill, you should never leave unat-

tended when in use. Turn off the gas supply at the gas container after use. k)

The gas grill should be cleaned after use. Don’t obstruct the re opening of the

container compartment. If the re opening is obstructed, please use Φ1.6mm

round stick to dredge. Take care not to enlarge burner ports or orice/nozzle

openings when cleaning the burner or valves.

l) Do not attempt to use this appliance in a garage or any enclosed area. Also

this appliance must be keep away from ammable materials, etc. We recom-

mend keeping a distance of at least 0.5 to 1.0 meter clear of any ammable

materials.

m) We would recommend that this gas grill should be serviced by your local

gas retail outlet at least once a year by a competent engineer. Do not attempt

to service this appliance yourself. n) Any modication of the appliance may be

dangerous. Do not attempt any unauthorized interference of the main controls

on this gas grill, i.e. gas taps, injectors, valves etc.

EN

Figure 3

WARNING: The Handle Black Area (See Above Picture for Reference)

Will Become Hot When the Gas grill In Use, BE CAREFUL! Do Not

Touch The Black Area.

6. Safety precautions

a) Always test gas line for leaks at connector with soapy water after

making connections.

b) The top lid must always be open when lighting the burner.

c) Use oven gloves and sturdy, long handled gas grill tools when

cooking on the grill.

d) Be prepared if an accident or re should occur. Know where the

rst aid kit and re extinguishers are and know how to use them.

e) Keep any electrical supply cord and the fuel supply hose away from

any heated surfaces.

f) Always cook with great care.

g) Do not heat any unopened glass or metal container of food on the

grill. Pressure may build up and cause the container to burst, possibly

resulting in serious personal injury or damage to the grill.

7. Lighting instructions

Caution: The lid must be open when lighting the burner!

Do not stand with your face directly over the gas grill when

lighting it. Your gas grill will have following method of ignition:

Pilot Gas Control Ignition(Main burner or main burner with side burner

or main burner with side burner and back burner ):

With all gas controls on the Gas grill in the “OFF” position“ OFF”, turn

the gas cylinder valve to the on position at the regulator. To create a

spark you must press the gas control knob (A) and hold in this position

for 3-5 seconds to allow gas ow and then turn anticlockwise to” HI”

(B). It can spark to the burner lighting tube (C). You will hear a “snap”

from the igniter and you will also see a orange ame coming from the

burner lighting tube at the left side of the burner (D). Continue to hold

the gas control knob in for two seconds after the “snap”, this will allow

gas to ow completely down the burner tube (E) and insure ignition.

When the burner is alight, adjacent burners will cross light when their

controls are turned to “HI” At “HI” setting the burner ame should be

approximately 12-20mm long with a minimum of orange ame. Turn

the gas control knob fully anticlockwise for minimum setting. Should you have

any difculty lighting your gas grill following the above steps, contact your

dealer for advice.

If the automatic ignition can’t be used, please remove the cooking grill and

heat diffuser(hotplate ), and turn the valve anticlockwise to 90°C to light with

BBQ lighter in the distance of 5mm to the burner re hole. Replace the cook-

ing grill and heat diffuser (hotplate), please wear the reproof and heat resist-

ing gloves.

Warning : If the burner still does not light ,turn the gas control knob to” OFF”

and wait for 2 minutes for the unburnt gas to evaporate before lighting again.

Figure 4

WARNING

For Your Safety

This grill has been made to high quality standards. NOTE: The use and instal-

lation of this product must conform to local codes.

IMPORTANT NOTICE: read all instructions prior to assembly and use. Read

and understand all warnings and precautions prior to operating your grill.

Main burner

EN CAUTION

1. This grill is for use with gas only.

2. Do not attempt to move the grill while it is lit.

3. Do not use the grill unless it is completely assembled and all parts

are securely fastened and tightened.

4. Keep all combustible items and surfaces at least 36 inches

(91.4cm) away from grill at all times.

5. DO NOT use this grill near unprotected combustible constructions.

6. Do not use in an explosive atmosphere. Keep grill area clear and

free from combustible materials, gasoline and other ammable

vapors and liquids.

7. Do not touch metal parts of grill until it has completely cooled

(about 45 minutes) to avoid burns, unless you are wearing protec-

tive gear (BBQ mittens, pot holders, etc.)

WARNING

1. This grill is for outside use only, and should not be used in a build-

ing, garage or any other enclosed area.

2. The use of alcohol, prescription or non-prescription drugs may im-

pair the 9 operator’s ability to properly assemble or safely operate

the grill.

3. Always open grill lid slowly and carefully as heat and steam

trapped within the grill can burn you severely.

4. Always place your grill on a hard, level surface far away from com-

bustibles. An asphalt or blacktop surface may not be acceptable

for this purpose.

5. Do not leave a lit grill unattended. Keep children and pets away

from the grill at all times.

6. Do not place this grill on any type of tabletop surface.

7. Do not use the grill in high winds.

PLEASE PAY ATTENTION

1. The barbecue has to be installed on a secure level base prior to

use.

2. The barbecue shall be heated up and the fuel kept red hot for at

least 30 min prior to the rst cooking.

3. Do not cook before the fuel has a coating of ash.

4. WARNING! This barbecue will become very hot, do not move it

during operation.

5. Do not use indoors!

6. WARNING! Do not use spirit or petrol for lighting or re-lighting!

Use only relighters complying to EN 1860-3!

7. WARNING! Keep children and pets away

Pagina se încarcă ...

Wellis Cherokee Silver Quintet Manual de utilizare

Acest manual este potrivit și pentru

Wellis Cherokee Silver Quintet Manual de utilizare

în alte limbi

Lucrări conexe

Alte documente